SAGINAW, TEXAS—
CTI FOODS
Caught between rolling powered vehicle and other object · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at CTI FOODS, 504 SANSOM BLVD, SAGINAW, TEXAS 76179 on — Fractures, affecting the toes(s), toenail(s).
Final narrative
When an employee stepped off of a forklift to disconnect it, the unit moved, catching his foot between the forklift and the battery charging station. The employee broke bones in his toes.
More severe injuries at CTI FOODS
SAGINAW, TEXAS—
CTI Foods
On September 9, 2024, at approximately 10:13 a.m., an employee opened the doors to a can opener to make routine mechanical adjustments. When the employee went to close the doors to the equipment, the distal tip of his left ring finger (above the nail) was struck by the closing door, resulting in a partial amputation.
SAGINAW, TEXAS—
CTI Foods
An employee was cleaning out a kettle when the contents in the kettle overheated, boiled out, and splashed him. He sustained chemical burns on his right arm, back, and hips.
View CTI FOODS's full OSHA safety record →
Similar incidents · Same event type
WILKES BARRE, PENNSYLVANIA—
Chewy, Inc.
On December 13, 2023, an employee was operating a forklift. When they stepped off the forklift, it crushed their left foot between the lift and a racking system. The employee suffered a foot fracture that required hospitalization.
FOUNTAIN, COLORADO—
Windigo Logistics Fountain
An employee was maneuvering a motorized pallet jack while standing in front of it. He became pinned between the pallet jack and a steel rack cross-beam, resulting in a contusion to his chest/back and a fractured rib.
ATLANTA, GEORGIA—
The Whitaker Company
An employee was stacking empty drums into a trailer. The employee then exited the trailer, using the forks of a forklift as a step. The forklift's parking brake failed, causing the forklift to move forward and pin the employee's right leg between the forklift and the trailer. The employee's right lower leg was crushed, resulting in a fracture and a laceration.
SAN ANTONIO, TEXAS—
Texas Multi-Chem, Ltd
An employee had been spraying weeds behind a school. As he was leaving the field, the employee drove his truck up to the gate, got out, and opened the gate. The truck rolled forward and pinned him against the fence/gate. The gate then gave way and opened from the force of the truck. The employee's left index fingertip got caught in the fence/gate and was amputated.
TEMPLE, TEXAS—
PactivEvergreen, Inc.
An employee was using a walk-behind tugger to pull a grinder. The employee's left little finger was pinched between the handle of the tugger and the framework of a staircase. The employee's fingertip was amputated.
More severe injuries in this industry (NAICS 424510)
CANAL WINCHESTER, OHIO—
Faler Feed Store, Inc.
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
LEOLA, SOUTH DAKOTA—
Agtegra Cooperative
An employee was walking past a crossover conveyor when a ramp came down and hit them in the back. The employee sustained a broken back vertebra, as well as a concussion, and was hospitalized.
MEADE, KANSAS—
Alliance Ag and Grain LLC
An employee bent over to pick up a rubber mat from the ground. When he grabbed the corner of the mat, a rattlesnake hidden under it bit his left middle finger near the first knuckle. He was hospitalized.
CHAPMAN, KANSAS—
Agri Trails Co-Op
An employee had been cleaning a grain bin. He walked across the bin and his left foot contacted an unguarded floor auger, resulting in severe lacerations to the foot. The auger was not locked out/tagged out at the time.
HICKORY RIDGE, ARKANSAS—
Riceland Foods, Inc.
On September 23, 2025, an employee was monitoring a feed roller when they tripped and their right hand contacted the roller. The employee was hospitalized and their right hand was amputated at the wrist.
More severe injuries in TEXAS
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
LUBBOCK, TEXAS—
Professional Flooring Supply
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
HOOKS, TEXAS—
EnviroSafe Demil LLC
An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
HALLETTSVILLE, TEXAS—
Regency IHS of Fairwinds Halletsville, LLC
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.