U.S. Dept. of Transportation, Federal Aviation Admin., Minneapolis Air Traffic Control Tower

An employee was transporting a patient to their residence. The employee bent down to grab a stretcher and felt a pop in their back. The employee sustained a herniation of their L4-L5 disc.

On November 18, 2023, at approximately 8:30 a.m., an employee was loading products onto a delivery truck. The employee lost footing and sustained a torn hamstring and a hematoma with nerve damage to his foot/leg.

An employee was carrying a pipe when it slipped from their hand. As they reached to grab it while it was falling, they felt a muscle pull. The employee was hospitalized for an abdominal hernia.

On August 21, 2023, an employee was reaching for product on the shelf in the cooler when their back gave out. The employee was hospitalized for an exacerbation of bulging disks.

An employee was vacuuming the inside of a used car when they sustained a lower back strain during the repetitive work, requiring hospitalization.

An employee turned off a pushback tractor at a gate, put it in neutral, and put the emergency brakes up. The employee then exited the tractor and noticed it was rolling forward toward the aircraft. The right side of his body was wedged between the tractor and the aircraft nose. The employee was hospitalized for fractured ribs and a partially collapsed lung.

An employee was on a 6-foot ladder conducting maintenance on a ballast above the ceiling in a hallway. When the employee removed the ballast he was shocked with 208V of electricity and fell off the ladder, landing on his left shoulder. The employee suffered an electric shock and a dislocated shoulder.

An employee was removing cable from a rigid conduit using a wire tugger. The device lifted up off the floor and the employee tried to push it back down. The employee's right hand was caught in the mule tape on the motor, amputating the index, middle, and ring fingers, and partially amputating the little finger.

An employee was on a ladder replacing lights on an ATC tower. He slipped off a rung of the ladder and fell to the ground, sustaining broken ribs.

An employee was leaving their vehicle to place cones on the street for traffic control. A car struck the employee, who suffered a broken cheekbone. The employee was hospitalized.

An employee was walking in a garage toward her delivery vehicle. As she stepped down a curb near her vehicle, she fell and landed on the concrete garage floor, resulting in a hip injury that required hospitalization.

Employees were performing maintenance operations on a railroad line when the machine experienced a load conveyor motor failure. While clearing the machine to allow for repairs, an employee pinned the left side of the swing conveyor. The operator on the right side then requested a slight bump to the left to align the right side for pinning. Once the swing was in position, the operator went to pin the right side and the chain tensioner failed, resulting in an abrupt release of the swing chain. The chain snapped back and struck the operator s right hand, resulting in a 1-inch laceration and a fractured fifth metacarpal. The employee was hospitalized and required surgery on the hand.

At about 9:15 a.m. on March 10, 2025, an employee was riding along a hardpack snow-covered roadway on a snowmobile. The snowmobile went over a berm and tipped/rolled, causing the employee to fall to the ground. He suffered a collapsed left lung and was hospitalized.

An employee was decommissioning a substation. The tower switch was being set down on the ground when the switch blade moved. The employee's finger was crushed and amputated.

An employee was struck by a truck and sustained a broken right leg.