Struck by object falling from vehicle or machinery-other than vehicle part · Cuts, lacerations
At a glance
Federal OSHA recorded a severe workplace injury
at Headwaters Resources, Inc., headwaters Resources, Inc., ACKERMAN, MISSISSIPPI 39735
on — Cuts, lacerations, affecting the hand(s), unspecified.
Final narrative
An employee was using an air chisel to chisel coal ash from the inside of a chute when a piece of ash fell from the chute and struck the employee's left hand, causing a 3-inch laceration.
An employee was transporting an 800-pound die on a cart from the tool room. The employee was pulling the cart when it struck a metal plate on the floor. This caused the cart to tip forward and the die to slide off the cart. The die struck the employee's left foot and their second toe was amputated.
An employee was using a forklift to load pallets of product on a trailer. He exited the forklift to adjust a pallet by hand. The pallet fell on him, resulting in an injury to the left leg.
An employee was lifting a 500-pound steel counterweight off a pallet using a magnetic hold jib crane. The counterweight detached from the crane and the employee sustained a left foot/toe fracture that required surgery.
An employee was using a pipe wrench to turn a 42-foot-long steel pipe on jack stands to weld the bottom portion. The pipe fell off the stands, striking the injured employee on his left shin. The employee sustained a left leg fracture at the shin area as well as a tibia fracture that required surgery.
More severe injuries in this industry (NAICS 424990)
An employee was walking into an aisle from between machines when they were struck by a forklift that was turning in to the aisle. The employee sustained head trauma.
An employee was checking temperatures to a side seal assembly when the side seal bar pinched the inside of his right middle fingertip causing an amputation.
An employee was parking a standup powered industrial vehicle (PIV) after moving pallets in a warehouse when they struck a stationary forklift, resulting in an ankle injury.
An employee was operating a forklift with a hopper attached. The chain that holds the hopper in place was stuck between the forklift prongs. The employee was working to free the chain when the forklift forks fell on their left forearm causing a severe laceration.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
The injured employee was standing behind a table. She jumped out to scare another employee, but tripped and fell on the tile floor, injuring her right ankle/foot. She was hospitalized with a dislocated ankle that required surgery.
An employee was going into a trailer to mark product for shipment and the trailer pulled away from the dock. The employee fell out of the trailer, contacted the dock plate, and then fell to the ground. The employee was hospitalized with a punctured lung, fractured ribs, and contusions.
An employee was hooking up bundled tie-downs with a chain. While he was holding a hook, the other hook was unlocked. This caused the employee's hook to slide down and pinch his right index finger between the chain and the shackle. He suffered an amputation to the fingertip (without bone loss), as well as an open fracture.
An employee was operating a gas tugger to lift metal sheeting. His left hand was pulled into the pulley, which crushed his left thumb, resulting in avulsions and other tissue damage. He was hospitalized and required surgery.