Fall from collapsing structure or equipment more than 30 feet · Soreness, pain, hurt-nonspecified injury
At a glance
Federal OSHA recorded a severe workplace injury
at Emerald Acres , 5795 Dickinson Rd., DE PERE, WISCONSIN 54115
on — Soreness, pain, hurt-nonspecified injury, affecting the multiple trunk locations.
Final narrative
Two employees were inside the top of a silo that was filled with corn silage. The employees were positioning an un-loader in the top of the silo to remove the silage. Another employee was positioned at the base of the silo. The employees heard a popping noise and the silo tipped over to the west. The two employees were free moving inside the silo cap and rode it down to the ground. The first employee suffered pelvic and rib injuries. The second employee suffered shoulder, rib, and lung injuries. Both were hospitalized.
An employee was adjusting a scaffold when the scaffold collapsed, causing the employee to fall approximately 145 feet to the ground. The employee was hospitalized with a fractured pelvis and broken bones in their back.
A lineman was tied off at the top of a power pole, lowering a deactivated power line from the pole. The base of the pole broke and fell; the lineman fell approximately 40 feet, sustaining injuries to the hip and the side of his body. He was hospitalized.
At 1:00 p.m. on September 15, 2022, an employee was on a utility pole disconnecting its cross-arms. The pole broke and the employee fell with it onto adjacent tree branches, then to the ground 30 feet below. The employee was hospitalized for multiple contusions and fractures to the head and torso as well as internal bleeding.
An employee was installing a beam when the other beam he was using as an anchor point for his fall arrest system failed. The employee fell 45 feet to the ground, resulting in broken ribs.
An employee was working on top of an elevator car removing counterweights. The elevator car was being lowered when the coffing hoist holding it up snapped and the elevator car and the employee fell from the 10th floor to the basement. The employee sustained broken bones.
More severe injuries in this industry (NAICS 112120)
Employees were stripping parts off an old pivot. An employee was standing on the ground, helping others make sure that the parts all came off the pivot. The pivot span was elevated when the base beam broke free on one side. This shifted the weight of the span, causing it to roll off the loader on its side. When the span came down, the support rod caught the employee's back as he went to turn and run away from it. It pushed him to the ground. He suffered a back fracture, along with a broken bone in his foot, and was hospitalized.
An employee was working in a holding pen, using a crowd gate to herd cows into milking stalls. She was moving to beat the crowd gate to a manhole, but the gate moved and struck the employee. The employee was hospitalized with two fractured processes in her lower vertebrae.
Three maintenance employees were working on chemical lines feeding into a large above ground wastewater treatment tank. Sodium hydroxide and sulfuric acid reacted in a floor drain and the chemicals sprayed onto the three employees. One employee was taken to the hospital for burns to his eyes.
An employee was removing a pin from a metal gate to let cows out of a parlor. The gate moved and his left middle finger was caught in the pin hole. The employee's finger was partially amputated.
The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.
An employee was using a vertical band saw to cut a thick piece of rubber material. While being cut, the material shifted, causing the employee s right hand to contact the moving blade. The employee's thumb was amputated below the knuckle. The employee was hospitalized, undergoing surgery.
A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.
An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.
An employee was unloading a truck for a delivery job. While moving boxes in the truck, the employee tripped over a pallet and fell out of the truck to the ground, resulting in four broken ribs.