Struck by discharged object or substance · Puncture wounds, except gunshot wounds
At a glance
Federal OSHA recorded a severe workplace injury
at HIGHWAY TRANSPORT, INC., 520 S. 16th Street, LA PORTE, TEXAS 77571
on — Puncture wounds, except gunshot wounds, affecting the foot (feet), unspecified.
Watch Highway Transport, INC. — freeGet an email when a new federal OSHA severe-injury report for Highway Transport, INC. is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was pressure washing a valve when the tip of the pressure washer contacted his left foot and the water stream penetrated his rubber boot just below the left pinky toe, resulting in a puncture wound.
An employee had just hooked up to a bulk chemical trailer and was performing a pre-trip inspection. Caustic soda ash blew from a rail car inside the plant and the employee sustained chemical burns to the eyes, face, throat, and lungs.
An employee was installing wood trim surrounding a skylight inside a home. While holding a piece of trim in it's desired location, his pneumatic nail gun discharged, sending a 3/4-inch pin nail into his left forearm.
An employee removed a safety valve on a trailer that unknowingly contained nitrogen gas. The gas released from the trailer and pushed the employee backward off a scaffold approximately 10 feet before they struck a garage door, resulting in a pelvic injury.
An employee was sitting at her workstation when a nail gun malfunctioned and shot a nail into her left leg. She suffered a puncture and blood vessel injury and was hospitalized.
On November 25, 2023, an employee was using a high-pressured water hose to perform sewer line cleaning operations. The employee's right little finger and palm were lacerated by pressurized water from the hose.
An employee had dumped a load of hot mix (tar) and was cleaning the interior walls of a belly dump trailer onsite. The employee was scraping the walls of the trailer when the doors articulated, breaking the securement pin and pinching the employee's legs. The employee sustained crushing injuries and severed tendons and arteries to both legs and was hospitalized.
An employee was transferring sulfuric acid into a customer's tank. They connected the transfer hose to the receiving tank and attached the compressed air line used to pressurize the trailer. An air valve opened during unloading and a small amount of sulfuric acid got under the employee's face shield and onto their face. The employee suffered third-degree chemical burns to their face, right ear, and chest.
An employee was working to adjust a misfed pallet board that was entering the pallet board collection point. His left middle fingertip became caught between the board he was adjusting and other boards already stacked in the collection area. This resulted in amputation of the fingertip.
On July 22, 2025, at approximately 4:30 a.m. after the previous day's shift, an employee was hospitalized with a kidney injury caused by heat-related illness. The employee had worked several consecutive days delivering packages in high outdoor heat and humidity without cooling gear.
On July 18, 2025, an employee was tarping a load on a flatbed trailer in the yard. He fell approximately 13 feet off the loaded trailer and landed face-down on a gravel lot. The employee sustained facial cuts, abrasions, scrapes, fractures to their face, as well as several fractured ribs. He was hospitalized.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.