Caught in running equipment or machinery during regular operation · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Berkel & Company Contractors, Inc., 8000 Jefferson Davis Highway, RICHMOND, VIRGINIA 23297
on — Amputations, affecting the fingertip(s).
Final narrative
An employee was prepping a piece of drill steel for a hole being drilled. The last piece of drill steel in the carousel had a tricone bit attached to the bottom. The employee tightened the jaws on the drill rig to loosen the tricone. When the employee opened the jaws to remove the tricone, his left thumb was caught between the backside of the jaws and the receiver. The tip of the thumb was amputated just above the nailbed.
An employee was pulling a 1-inch hose into position. He stepped down a small embankment (about 18 inches in height), lost his balance, and fell on the ground. The employee sustained two fractures to his left leg, requiring hospitalization and surgery.
Two employees were installing center bars, plates, and nuts on cased micropiles. As one employee was holding the center bar with a pipe wrench, the injured employee went to lift the plate. The wrench was released which caused the nut to catch and pull the plate down. The employee's right ring finger was caught between the plate and the casing; the first digit was amputated.
While digging pits under the foundation of the building, a piece of concrete fell and struck two employees. One employee was treated and released with a hand injury; the second employee was hospitalized with a chest injury.
An employee was sharpening peeler blades when their shirt was caught in the grinding wheel. The employee sustained tendon damage and a crushed right hand.
An employee was preparing to cut lumber on a panel saw when the clamp engaged and caught the employee's left middle finger, resulting in a fingertip amputation.
More severe injuries in this industry (NAICS 238910)
An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.
An employee was assisting the crew with patching and restoring a roadway after the installation of a sewer line. He was helping place and level the blacktop/backfill material over the trench area to bring the road surface back to proper grade. The employee was walking between a forward-moving dump truck and a dirt pile when his right foot was run over by the truck s wheel, causing him to fall. The employee sustained injury to his foot.
An employee was operating a skid steer with a bucket attachment at a demolition site. While driving it to the rear of the property to park it, the employee came into contact with a live electrical transformer unit that was located outside of the facility. The employee sustained electrical burns on his hands extending up to his elbows and a fractured ankle.
An employee was installing a door on a semi-trailer. They were using a forklift to lift the door to the height of the trailer when the door became jammed between the forklift mast and the hinge on the trailer. When the employee went to dislodge the door from the mast, the door fell and crushed their foot. Their big toe was amputated. The employee was hospitalized and their big toe was surgically reattached. The employee's foot and other toes also required surgery.
A building engineer was inspecting a generator. As he closed the generator enclosure door, his right ring finger was caught between the door and the door frame. The fingertip was amputated.
An employee was walking back to a carrier case with mail in her hand when she tripped over a tub. Her back overarched as she fell, resulting in a fractured back that required hospitalization.
An employee was driving a utility tractor rig when it struck the rear trailer of another utility tractor rig, which was traveling in the opposite direction. The glancing impact caused damage to the cab, and he sustained a laceration on right side of his face, a cervical fracture, two fractured left ribs, and a pelvic fracture. The employee was hospitalized.
An employee was washing an aircraft from a scissor lift when they fell to the floor. The employee sustained a back injury and lacerations to their head and neck.