ATHENS, ALABAMA—
Day & Zimmermann NPS, Inc.
Other fall to lower level less than 6 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at Day & Zimmermann NPS, Inc., 10833 Shaw Road, ATHENS, ALABAMA 35611 on — Fractures, affecting the hip(s).
Final narrative
An employee was dismantling a frame scaffold. The employee stepped up onto the bottom rung of the frame to hand another employee a piece of diamond plate. As the employee stepped back down from the rung, his foot slipped and he fell 2 feet to the concrete floor. He was hospitalized with a fractured left hip.
More severe injuries at Day & Zimmermann NPS, Inc.
HAYWOOD, WEST VIRGINIA—
Day & Zimmermann NPS, Inc.
An employee was using a chain fall to install a liner in a mill. As he was setting the liner in place, his right index finger got stuck in a chain on the rigging, resulting in a fingertip amputation that required hospitalization and a surgical reattachment.
COLUMBIA, ALABAMA—
Day & Zimmermann NPS, Inc.
An employee was descending a fixed 15-foot ladder. The employee slipped and fell, landing on a snubber machine 8 feet below and suffering a laceration to the left thigh and a fracture to the sternum.
MIDDLETOWN, CONNECTICUT—
Day & Zimmermann NPS, Inc.
On September 21, 2020, an employee was performing boiler maintenance and was using a 6" hand held angle grinder with a wafer cutting wheel to cut block welds in order to remove the cyclone tubes for replacement. While cutting, the cutting wheel became pinched and the grinder kicked back. The employee lost control of the grinder and sustained a laceration on his right leg above the knee that required sutures and hospitalization.
PORT WASHINGTON, WISCONSIN—
Day & Zimmermann NPS, Inc.
An employee slipped and fell while descending a fixed ladder. The employee's hard hat then lacerated the back of the employee's head.
View Day & Zimmermann NPS, Inc.'s full OSHA safety record →
Similar incidents · Same event type
JACKSON, MISSOURI—
Electrical Contractors Inc.
An employee was climbing a step ladder while carrying a 3-foot piece of conduit. As he went to reposition his feet on the ladder by pivoting, he slipped and fell from the third rung of a 6-foot ladder. The employee sustained fractures to the left femur, right elbow, and right ring finger.
FORT RUCKER, ALABAMA—
M1 Support Services
An employee was descending a 4-step maintenance stand when she missed the bottom step and fell to the hangar floor. The employee suffered a left hip fracture.
PHILADELPHIA, PENNSYLVANIA—
FEDEX Ground Package System, Inc.
An employee stopped a belt and was going to check it for missing packages. She fell backward 3-4 feet from an elevated platform and sustained a broken right arm.
LAFAYETTE, COLORADO—
SRM Concrete
An employee had just finished a routine concrete pour and was ascending the ladder to clean the concrete mixer truck. The employee lost their grip and fell approximately 2-3 feet, contacting the truck's bumper. The employee suffered rib fractures and a punctured lung.
LOS ANGELES, CALIFORNIA—
U.S. Postal Service - Los Angeles P&DC
An employee was performing duties as an expeditor. After opening the dock door, the employee scanned the barcode on the door of the truck and placed one foot on the truck and one foot on the dock. The truck drove out of the stall, causing the employee to fall 4 feet off the dock onto the concrete. The employee sustained fractures to the right side of the pelvis, elbow, and a left ring fingertip as well as injuries to the right wrist and bruising to the back and stomach.
More severe injuries in this industry (NAICS 238990)
LISLE, ILLINOIS—
Stevenson Crane Service, Inc.
A crew was relocating a dumpster (containing approximately 200 pounds of demolished wire) to access the uninterruptible power supply (UPS) units they were servicing. During movement of the dumpster, a section of carpet tile dislodged from the floor, causing an employee to lose his footing, slip, and fall. He landed on his right wrist, resulting in a fracture.
EXCELSIOR SPRINGS, MISSOURI—
Champion Replacement Windows of Kansas City
An employee was cutting a board using a circular saw. The saw pinched, kicked back, and cut the employee's left ring and little fingers. The employee suffered an amputation to the little finger.
OVIEDO, FLORIDA—
Severo Ortiz Construction LLC
An employee was using an aluminum extension ladder to remove gutters at a height of approximately 20 feet. As they were removing the gutters, part of the gutter collapsed and struck the ladder, causing it to move sideways. The employee fell from the ladder and sustained fractures to ribs on the left side and their right forearm.
MISSION HILLS, KANSAS—
Fence Repair Company
An employee was using an electric saw to cut a piece of wood for a fence. The saw slipped out of his hand and lacerated his left leg. He was hospitalized.
PLYMOUTH MEETING, PENNSYLVANIA—
Beth-Allen Scaffold & Equipment
An employee was erecting a scaffold. A side bracket was not secure. The employee stepped on the bracket to test it and fell 18 feet to the concrete floor resulting in fractures to the ankles and femurs. He was not using fall protection equipment.
More severe injuries in ALABAMA
GENEVA, ALABAMA—
Sysco Gulf Coast, LLC
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
BESSEMER, ALABAMA—
Norflex, Inc.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
ANNISTON, ALABAMA—
Ampler Pizza II LLC
An employee was shot in the leg with a pistol during an altercation with two people who had entered the store without permission.
ATMORE, ALABAMA—
Birdsong Corporation
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
ROGERSVILLE, ALABAMA—
Pilgrims
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.