Other fall to lower level 6 to 10 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at PJ Dick Incorporated, 626 Washington Place, PITTSBURGH, PENNSYLVANIA 15219
on — Fractures, affecting the lower leg(s).
Watch PJ Dick Incorporated — freeGet an email when a new federal OSHA severe-injury report for PJ Dick Incorporated is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was installing a two-by-four knee wall as part of a supported deck forming operation. The employee was wearing a personal fall arrest system (PFAS) consisting of a full-body harness and a retractable lanyard. As the employee was moving to install the knee wall, he reached the maximum cable length and the lanyard retracted, causing him to lose balance and fall. The employee fell approximately 6 feet, landing on top of a material bin that was staged on the level below. The employee sustained a fracture to his lower left leg.
An employee was working inside a stair core when a taper tie fell from the north concrete wall form and struck his hard hat. The employee was hospitalized with a fractured C3 vertebra.
An employee was preparing a tank car for loading while chipping away solidified product in the manway opening of the tank car. A pressure noise within the tank car startled the employee, causing him to stumble backward and fall approximately 10 feet over the guard railing at the chemical loading rack to the ground. The employee suffered fractured vertebrae, a fractured right wrist and ankle, and a dislocated jaw.
An employee was installing an electrical tray remover from a ladder. As he was descending, his missed a step and fell 6-7 feet to the floor. The employee suffered a head injury.
Two employees were installing spray foam insulation in the attic of a new residential construction. The injured employee fell 8 feet from an A-frame ladder to the floor. The employee suffered lacerations, abrasions, and a head injury.
An employee was on a raised platform attaching wires to electrical boxes. The employee fell approximately 8 feet to the floor below and struck an exit sign on the way down, resulting in an injury to his face.
An employee was in a forklift man basket fixing a garage door opener when they fell approximately 8 feet to the concrete ground below. The employee suffered head and back injuries as well as kidney bruising.
More severe injuries in this industry (NAICS 236116)
An employee was adjusting the forks on a skid steer when his right index finger got pinched between the forks and the frame of the skid steer. The finger was crushed and required partial amputation of the fingernail area.
An employee was helping to install a marble plank when the plank fell on his hand. His fingers became caught between the plank and the floor, resulting in partial amputations to two fingers.
The injured employee was walking in front of the property by the front door as another employee was removing debris from the roof. The injured employee was struck by a 2 x 4 that was being cleared from the roof. He was knocked unconscious and sustained brain bleeding, as well as head and facial injuries, and required stitches.
An employee had been tasked with hauling large rocks. There was a rock caught in the tailgate of the dump truck that was preventing it from opening. He went to get the rock out and the tailgate came down, crushing his right middle fingertip. The employee sustained a fracture of the distal phalanx and required surgery.
An employee was working in a trench that was 3.5 feet deep when soil fell and hit them, resulting in an injury to their pelvis. The employee was hospitalized.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.