Struck by discharged object or substance · Puncture wounds, except gunshot wounds
At a glance
Federal OSHA recorded a severe workplace injury
at Douglass Distributing, 325 East Forest Avenue, SHERMAN, TEXAS 75090
on — Puncture wounds, except gunshot wounds, affecting the hand(s), unspecified.
Watch Douglass Distributing — freeGet an email when a new federal OSHA severe-injury report for Douglass Distributing is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was helping perform maintenance on a new high pressure grease pump prior to delivering it to a customer. The high pressure grease cracked the fitting and lacerated the employee's hand at 5,600 psi. Grease was injected into the wound. The employee was not wearing PPE at the time.
An employee was installing wood trim surrounding a skylight inside a home. While holding a piece of trim in it's desired location, his pneumatic nail gun discharged, sending a 3/4-inch pin nail into his left forearm.
An employee removed a safety valve on a trailer that unknowingly contained nitrogen gas. The gas released from the trailer and pushed the employee backward off a scaffold approximately 10 feet before they struck a garage door, resulting in a pelvic injury.
An employee was sitting at her workstation when a nail gun malfunctioned and shot a nail into her left leg. She suffered a puncture and blood vessel injury and was hospitalized.
On November 25, 2023, an employee was using a high-pressured water hose to perform sewer line cleaning operations. The employee's right little finger and palm were lacerated by pressurized water from the hose.
A forklift lifting device was being picked up with a forklift. The forks were lowered, causing the equipment to fall and injure an employee. The employee sustained cervical spine, facial, and jaw injuries and was hospitalized.
An employee was refilling a bottle with a cleaning solution when bleach entered the bottle and it exploded. The employee inhaled the fumes and experienced difficulty breathing and burns to her throat, resulting in hospitalization.
An employee was performing maintenance on a pump flange that was in ammonium sulfate service. The line had been blocked in and drain lines were opened. The employee was making a line break when hot sulfur water (150-180 degrees) sprayed out. The employee sustained thermal burns to their chest, back, arm, and stomach.
An employee was measuring the level in a storage tank using a handheld tape gauge. When he stood up, he felt a sharp pain in his back. He was hospitalized, having suffered a lower back strain.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.