ALIQUIPPA, PENNSYLVANIA—
Trinity Solar
Exposure to environmental heat indoor · Heat exhaustion, fatigue
At a glance
Federal OSHA recorded a severe workplace injury at Trinity Solar, 1023 TEE LINE DR, ALIQUIPPA, PENNSYLVANIA 15001 on — Heat exhaustion, fatigue, affecting the BODY SYSTEMS .
Final narrative
An employee was working in an attic securing a wire conduit. Due to high temperatures, he left the attic, became ill, and experienced shaking and cramping. The employee was hospitalized and treated for heat exhaustion.
More severe injuries at Trinity Solar
AMHERST, MASSACHUSETTS—
Trinity Solar
An employee was drilling an access hole into the meter box of a residential property. The drill bit punched through the metal and hit a live conductor inside the box. The employee sustained an electrical arc flash burn to their hand and was hospitalized.
HANOVER, PENNSYLVANIA—
Trinity Solar
An employee was adjusting stabilizers at the top of a ladder, preparing to install solar panels. He fell from the ladder to the pavement 8 feet below, sustaining a broken left ankle.
WEST LAWN, PENNSYLVANIA—
Trinity Solar
An employee was installing solar panels when they slipped and fell from the roof to the ground. The employee sustained a broken ankle.
BRISTOL, CONNECTICUT—
Trinity Solar
An employee had accessed a snow-covered roof to set up roof anchors for a solar panel installation job. While he was clearing snow from the roof edge, he fell 18 feet to the ground below, suffering cracked ribs and a hairline fracture to his hip/pelvis.
EGG HARBOR TOWNSHIP, NEW JERSEY—
Trinity Solar
An employee on a ladder fell while reaching for his lanyard attachment.
View Trinity Solar's full OSHA safety record →
Similar incidents · Same event type
HOUSTON, TEXAS—
Whataburger
An employee was working on the grill when they began to feel ill. The employee was hospitalized to treat heat-related illness. The air conditioning was not working at the location.
HILLSBORO, TEXAS—
Overland Contracting, Inc.
An employee had been working in a fabrication area conducting preassembly of solar modules. The employee was hospitalized for heat-related illness, rhabdomyolysis, and renal failure.
JACKSONVILLE, FLORIDA—
Earl W. Colvard, Inc
An employee was working in the baking chambers of the tire retread center for 5.5-6 hours in approximately 100-degree heat. He developed severe pain and full body cramping. The employee was hospitalized with severe dehydration and heat exhaustion resulting in back pain and a kidney injury.
MONACA, PENNSYLVANIA—
Stoelzle Glass USA Inc.
An employee was working at an individual selection machine when he began to suffer heat stress, resulting in hospitalization.
FORT SMITH, ARKANSAS—
Gerdau
On August 8, 2025, an employee developed muscle cramps and dizziness. Later, while working on a plant floor, he developed full-body cramps. He was hospitalized, suffering from head exhaustion.
More severe injuries in this industry (NAICS 238210)
WASHINGTON, DISTRICT OF COLUMBIA—
Smart Building Technologies - A Fidelity Company
An employee was troubleshooting the control setup for a variable air volume box above a ceiling. The employee's hand came into contact with an exposed, energized 277-volt wire that had loosened from its terminal on the box's assembly. He was shocked and fell off a ladder. His left hand passed across the ceiling grid and was lacerated. He also suffered an electrical burn to the right hand and was hospitalized.
CANTON, OHIO—
Abbott Electric Inc
An employee was moving a scissor lift through a doorway. The employee was pinned between the scissor lift and the doorframe, sustained a back injury, and was hospitalized.
AVENTURA, FLORIDA—
Mintcrest Corp
An employee was standing on an A-frame ladder approximately 6 feet above the floor while he attached a suspended light fixture to the ceiling. The employee lost balance, and fell to the tiled floor below, sustaining blunt force trauma to his head.
KUNA, IDAHO—
Cupertino Electric, Inc.
An employee was inspecting the overhead area of a single-person lift and repositioning the lift through a double doorway. As they were transitioning through the doorway, they were caught between the doorframe and the vertical mast of the lift. The employee was hospitalized with injuries to the nose, left maxillary sinus, left orbital bone, and left jaw, with fractures at the maxillary sinus area.
AURORA, ILLINOIS—
Swedberg Electric, LLC
The injured employee was performing routine maintenance on a fan belt/pulley. The injured employee and another person were moving the pulley back and forth manually to find a bearing issue. The injured employee's left ring finger got caught between the belt and the pulley wheel, resulting in a soft tissue amputation.
More severe injuries in PENNSYLVANIA
WYNNEWOOD, PENNSYLVANIA—
Main Line Clinical Labs
An employee was closing a door when the door closed on their right index finger, resulting in a fingertip amputation.
POCONO SUMMIT, PENNSYLVANIA—
Ardent Mills
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
LANCASTER, PENNSYLVANIA—
Zimmerman & Herr
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
EBENSBURG, PENNSYLVANIA—
McAneny Brothers, Inc.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
PITTSBURGH, PENNSYLVANIA—
Metz Culinary Management LLC
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.