Fall from collapsing structure or equipment 11 to 15 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at Veyance Industrial Services, Inc., 12798 N Blackhawk Ln, MOUNT VERNON, ILLINOIS 62864
on — Fractures, affecting the hip(s).
Final narrative
An employee was guiding a forklift to set a roll of conveyor belting onto a stand on a table. The stand collapsed when the roll was set, and the employee was catapulted up and off of the table, landing 12 feet away on a concrete floor in a sitting position. He injured his right hip and buttocks and was hospitalized, and later had surgery to correct hip fractures.
An employee was removing a safety railing from a stairwell. The 2x10 plank they were standing on gave way and the employee fell approximately 12 feet to a lower level, resulting in fractures.
An employee was climbing a ladder to get to the top of a container. The ladder collapsed and the employee fell 13 feet to the concrete floor, sustaining a fractured pelvis and tailbone.
Two employees were cleaning the ducts on top of a pipe. The pipe gave way and the employees and the pipe fell 15 feet. The pipe landed on one employee's leg, resulting in a fracture in three places and hospitalization. The other employee was not injured.
An employee was walking on the roof deck performing roofing work when the deck collapsed. The employee fell approximately 13 feet to the ground below, resulting in fractures and bruising to the hips, head, and chest.
More severe injuries in this industry (NAICS 238910)
An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.
An employee was assisting the crew with patching and restoring a roadway after the installation of a sewer line. He was helping place and level the blacktop/backfill material over the trench area to bring the road surface back to proper grade. The employee was walking between a forward-moving dump truck and a dirt pile when his right foot was run over by the truck s wheel, causing him to fall. The employee sustained injury to his foot.
An employee was operating a skid steer with a bucket attachment at a demolition site. While driving it to the rear of the property to park it, the employee came into contact with a live electrical transformer unit that was located outside of the facility. The employee sustained electrical burns on his hands extending up to his elbows and a fractured ankle.
An employee was installing a door on a semi-trailer. They were using a forklift to lift the door to the height of the trailer when the door became jammed between the forklift mast and the hinge on the trailer. When the employee went to dislodge the door from the mast, the door fell and crushed their foot. Their big toe was amputated. The employee was hospitalized and their big toe was surgically reattached. The employee's foot and other toes also required surgery.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.