XPO Logistics, Inc.

An employee was standing on a loading dock near the end of a trailer. As the employee was stepping backward, they were struck on their right side by a crate that a forklift was transporting. The employee was pushed off balance and into a steel beam on their left side. They suffered a broken left arm.

An employee was delivering material to a jobsite, slipped off the lift gate of a truck and fell to the ground. The employee suffered a hip injury.

On October 5, 2022, at approximately 11:30 AM, an employee jumped off a semi-trailer from a height of approximately 4 feet. The employee impacted the ground, and was hospitalized with a broken bone in their right lower leg.

An employee was on top of a roof changing a light bulb. The employee fell through the roof to the concrete floor about 25 feet below, suffering a broken neck and three broken back vertebrae.

An employee opened a trailer's rear door and was struck on the right foot by forklift blades that had been stored on a pallet and shifted during transportation, resulting in a contusion.

An employee was walking in an aisle when a forklift backed up over her foot, resulting in a skin injury that required surgery to repair.

An employee was looking into the bucket of a front-end loader to see how much material was in it. A skid steer backed into the employee, who then fell into the edge of the front loader's bucket and suffered internal bleeding in the abdominal area.

An employee was spotting for a forklift operation. The forklift backed over the employee, who suffered a complete amputation to one lower leg and a partial amputation to the other leg. The employee was hospitalized.

An employee was cleaning his work area and preparing it to begin making air-set molds when a nearby forklift that was backing out from a load swung around and struck the employee. They sustained a lower left leg fracture.

An employee was walking around a work area when he was struck by a forklift that was backing up, resulting in several broken bones in his foot.

An employee had dumped a load of hot mix (tar) and was cleaning the interior walls of a belly dump trailer onsite. The employee was scraping the walls of the trailer when the doors articulated, breaking the securement pin and pinching the employee's legs. The employee sustained crushing injuries and severed tendons and arteries to both legs and was hospitalized.

An employee was transferring sulfuric acid into a customer's tank. They connected the transfer hose to the receiving tank and attached the compressed air line used to pressurize the trailer. An air valve opened during unloading and a small amount of sulfuric acid got under the employee's face shield and onto their face. The employee suffered third-degree chemical burns to their face, right ear, and chest.

An employee was working to adjust a misfed pallet board that was entering the pallet board collection point. His left middle fingertip became caught between the board he was adjusting and other boards already stacked in the collection area. This resulted in amputation of the fingertip.

On July 22, 2025, at approximately 4:30 a.m. after the previous day's shift, an employee was hospitalized with a kidney injury caused by heat-related illness. The employee had worked several consecutive days delivering packages in high outdoor heat and humidity without cooling gear.

On July 18, 2025, an employee was tarping a load on a flatbed trailer in the yard. He fell approximately 13 feet off the loaded trailer and landed face-down on a gravel lot. The employee sustained facial cuts, abrasions, scrapes, fractures to their face, as well as several fractured ribs. He was hospitalized.

An employee was cleaning leaves with a backpack blower when he fell from a ladder, resulting in injuries to his head, neck, and back.

An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.

An employee slipped while descending in a stairwell, fell, and suffered multiple contusions/bruises to the head, neck, shoulders, knees, and back. She was hospitalized.

An employee's right middle finger was caught in a nip point. The employee suffered an amputation to the middle finger at the first knuckle.

An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.