Caught in running equipment or machinery during regular operation · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Champion Home Builders, Inc., 501 S. Burleson Blvd., BURLESON, TEXAS 76028
on — Amputations, affecting the finger(s), fingernail(s), unspecified.
Final narrative
An employee was using a chop saw when the guard broke. The saw then cut his fingers, resulting in one partial finger amputation and one finger laceration.
At 7:30 a.m. on March 11, 2025, an employee was cutting angle iron pieces with a saw. When he went to stop the blade, it lacerated his right middle finger.
The injured employee was holding the rafters at the roof build table area while a co-worker attached them to the roof frame using a pneumatic nailer. A four-inch nail ricocheted and pierced the employee's left shoulder resulting in injury to an artery and the left lung.
An employee was using a miter saw to install molding during construction of a new mobile home and sustained severe lacerations to their right arm and hand.
An employee was standing on an A-frame ladder 3 to 4 feet above the ground, replacing the exterior siding of a home. The ladder tilted to one side, causing him to fall off. He suffered eight broken ribs and a collapsed lung.
An employee was sharpening peeler blades when their shirt was caught in the grinding wheel. The employee sustained tendon damage and a crushed right hand.
An employee was preparing to cut lumber on a panel saw when the clamp engaged and caught the employee's left middle finger, resulting in a fingertip amputation.
More severe injuries in this industry (NAICS 236115)
An employee was unloading frameless mirrors from a trailer. When unstrapped, the mirrors fell over onto the employee, who suffered a skull fracture, a brain bleed and blood clot, a broken left ankle, and lacerations.
An employee was drilling a hole into the sealed hold of a vessel so a marine chemist could test its atmosphere. Upon drilling the hole, a gas that was under pressure was released and caught fire at the drill motor, where the employee was holding it. The employee was burned.
An employee was inspecting the attic in a home. The employee stepped off the drop-down attic ladder onto drywall, fell through, and landed on the floor about 10 feet below. He suffered a broken left tibia.
An employee went aloft in a bucket truck to install a rubber cover-up for the pole set. He was proceeding to frame and transfer the conductors to the new pole when he sustained electrical burns on his left side, arm, and leg that required hospitalization.
An employee was positioned on a scaffold. They were using a level to adjust a pole and place bricks on the side of a wall. They fell approximately 30 feet from the scaffold to the ground, resulting in fractures to their back, rib, and heel.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.