Fluor Corporation

An employee was using an air-actuated pump to pump oil from a mill to a 55-gallon drum when the pump malfunctioned. The employee went to fix the pump when it activated and the piston contacted their left index fingertip, resulting in an amputation.

On June 13, 2025, an employee was applying sprayed concrete to the top of coke ovens in a tunnel that is typically around 200 degrees. Later in the day, they began to show signs of heat-related illness, resulting in hospitalization.

Employees were raising a structural steel beam (L 27' x W 24" x 104") when it fell striking the injured employee. They were lifting the beam using a beam clamp and a crane to orient it to slide in place to be bolted up. The injured employee's lower left leg was amputated. The employee also sustained serious injuries to the right leg, a bruised hand and a possible fractured cheekbone.

An employee was walking on a flatbed tractor trailer while loading equipment. He was checking to make sure chains were not trapped between the load and dunnage when he tripped over the dunnage and fell 57.5 inches off the trailer to the concrete below, fracturing his pelvis.

An employee was cutting a piece of plywood on a table saw when his left glove and hand were caught and pulled into the saw blade, amputating his index and middle fingers and lacerating his ring finger.

An employee was preparing a tank car for loading while chipping away solidified product in the manway opening of the tank car. A pressure noise within the tank car startled the employee, causing him to stumble backward and fall approximately 10 feet over the guard railing at the chemical loading rack to the ground. The employee suffered fractured vertebrae, a fractured right wrist and ankle, and a dislocated jaw.

An employee was installing an electrical tray remover from a ladder. As he was descending, his missed a step and fell 6-7 feet to the floor. The employee suffered a head injury.

Two employees were installing spray foam insulation in the attic of a new residential construction. The injured employee fell 8 feet from an A-frame ladder to the floor. The employee suffered lacerations, abrasions, and a head injury.

An employee was on a raised platform attaching wires to electrical boxes. The employee fell approximately 8 feet to the floor below and struck an exit sign on the way down, resulting in an injury to his face.

An employee was in a forklift man basket fixing a garage door opener when they fell approximately 8 feet to the concrete ground below. The employee suffered head and back injuries as well as kidney bruising.

An employee was cutting cabinet trim using a table saw when four fingers on his left hand were severed, resulting in hospitalization and amputation.

The injured employee was standing behind a table. She jumped out to scare another employee, but tripped and fell on the tile floor, injuring her right ankle/foot. She was hospitalized with a dislocated ankle that required surgery.

An employee was installing insulation in a wall when she tripped on a hole (12" deep) and fell, hitting her head on the concrete floor. The employee sustained fractures to her leg and wrist, and lacerations to her head. The employee was hospitalized.

An employee was loading a 4-inch wooden door into a pickup truck when he felt a pop in his right side behind his shoulder blade. He was hospitalized later that day and underwent surgery, having suffered a collapsed right lung.

An employee was operating a power drill when it slipped. The drill bit punctured the employee's hand and they were hospitalized.

An employee was cleaning leaves with a backpack blower when he fell from a ladder, resulting in injuries to his head, neck, and back.

An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.

An employee slipped while descending in a stairwell, fell, and suffered multiple contusions/bruises to the head, neck, shoulders, knees, and back. She was hospitalized.

An employee's right middle finger was caught in a nip point. The employee suffered an amputation to the middle finger at the first knuckle.

An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.