Struck by discharged object or substance · Cuts, lacerations
At a glance
Federal OSHA recorded a severe workplace injury
at TURNER INDUSTRIES, 26100 Highway 405 South, PLAQUEMINE, LOUISIANA 70764
on — Cuts, lacerations, affecting the hand(s), except finger(s).
Final narrative
At about 3:30 p.m. on May 25, 2018, an employee was in a cell renewal building, hydroblasting deposits from a cell body. A 4-foot section of hose connected to the blasting gun ruptured in the palm of their left hand, causing a laceration.
Two employees were replacing cartridge filters at the recycle oil filter in a hydrocracking unit. While removing compression springs from the top of the filters located within the filter pot, vapors that had accumulated within the filter tubes ignited, causing a flash fire. Both employees suffered burns to multiple body parts and were hospitalized.
An employee was inspecting a furnace. While removing an access door from the furnace, the employee's finger was pinched between the access door and the outer furnace beam support, resulting in amputation of the left little fingertip.
Two employees were setting a metal pipe in place for installation on a metal rack. When one employee pushed on the pipe, the other employee's left index fingertip was pinched between the pipe flange and a conduit. The employee's left index fingertip was amputated.
Employees were preparing to unload material with a crane. When the front outriggers were extended it contacted an employee's right foot resulting in a crushing injury and great toe amputation.
An employee was installing wood trim surrounding a skylight inside a home. While holding a piece of trim in it's desired location, his pneumatic nail gun discharged, sending a 3/4-inch pin nail into his left forearm.
An employee removed a safety valve on a trailer that unknowingly contained nitrogen gas. The gas released from the trailer and pushed the employee backward off a scaffold approximately 10 feet before they struck a garage door, resulting in a pelvic injury.
An employee was sitting at her workstation when a nail gun malfunctioned and shot a nail into her left leg. She suffered a puncture and blood vessel injury and was hospitalized.
On November 25, 2023, an employee was using a high-pressured water hose to perform sewer line cleaning operations. The employee's right little finger and palm were lacerated by pressurized water from the hose.
An employee was using a ballpeen hammer to hit a metal stud. A metal shard broke off from the stud and hit the employee's left eye. The employee was hospitalized for surgery, but did not lose their eye.
An employee was helping to troubleshoot a power interruption at a communications site when they were bitten by a rattlesnake. The employee was hospitalized.
An employee was reviewing paperwork that was placed on the front bumper of a digger truck when a skid steer backed over the employee's left foot. The employee sustained multiple foot fractures.
An employee was adjusting a floor jack under a 40-foot trailer. The trailer slid to one side and fell off the jack; the employee's right middle finger was crushed between trailer's lifting channel and the jack. The finger was amputated at the middle knuckle.
A driver was exiting his vehicle outside the plant gate when his foot slipped on the top step of the truck. He fell to the ground, landed on his left hip and elbow. The employee was hospitalized with a fractured hip/femur.
A security employee was responding to an urgent call from staff regarding a violent patient. The employee tripped and fell on the floor outside of the stairwell. The employee sustained a closed head injury, contusion of the cerebrum without loss of consciousness, and a closed fracture of the distal end of the right radius.
A temporary employee was testing an electrical starter motor. He was placing tape on the starter while the breaker was not engaged, but the starter sent an arc flash that burned his hands and stomach.
An employee was walking on a sidewalk and stubbed his toe on an elevated portion of concrete, causing him to trip and fall. The employee's right knee was dislocated.