American Sugar Refining, Inc.

An employee was using a motorized chain hoist to lift a pump weighing 600 to 700 pounds onto a working table. The hoist, which weighed approximately 100 pounds, fell from an overhead crane onto the employee s fingers, resulting in a finger amputation.

An employee was clearing a blockage of sugar when his finger contacted a moving screw conveyor. The employee's fingertip was amputated. The conveyor was not locked out at the time.

An employee was attempting to step onto a rolling rail car when his foot slipped and his right foot went under the rail car wheel amputating all five toes.

An employee was supporting a shaft that was in a vice during repairs when the shaft fell through the vice, hitting and partially amputating the employee's left ring finger.

An employee fell from the top of a tanker truck to the ground, breaking an ankle.

An employee was performing finishing work on a residential driveway when they began to experience body cramps and were hospitalized for heat stress and dehydration.

An employee was staking tomato plants on a farm. The employee began to feel sick and collapsed, suffering from dehydration and heat shock.

An agent was participating in SWAT team selection and was performing various physical fitness skills including running and exercise intervals. The agent experienced dehydration and a muscular injury that required hospitalization.

An employee was traveling back from work when they became ill and experienced dizziness due to heat exhaustion.

On September 26, 2023, an employee was delivering packages when he began to feel ill with a pain in his side. He was hospitalized for heat exhaustion and dehydration.

An employee was adjusting the flat scratcher of a sweep cultivator when the metal tube of the scratcher slid down and caught the tip of the employee's left thumb between the pipe and C-clamp. The employee sustained a left thumb tip amputation.

A crew was building a scaffold inside a furnace. An employee was stabilizing the mudsill and jack as a 10-foot scaffold leg was being connected. The scaffold leg came in contact with the furnace wall, causing a piece of refractory brick to fall. It struck the right side of the employee's mid-back, causing a contusion.

Employees were reinstalling the frame of a mechanical guard onto a raw sugar mixer. A chain fall was used to position the frame so it's weight was resting on the lower pedestal. The chain block was then unhooked, and an employee used a hammer to position the frame so the top bolt holes would be aligned. The bottom of the frame slipped off the pedestal and the frame fell two feet down onto the employee's right arm causing fractures to the radius and ulna.

An employee was tasked with identifying a conveyor system failure. When the employee opened the conveyor, a flash fire occurred. The employee sustained burns to the hands and face and was hospitalized.

An employee was operating package filling equipment when he attempted to loosen clumped sugar in the equipment piping and injured his right hand. He was hospitalized with fractures to four fingers on his right hand.

A driver was exiting his vehicle outside the plant gate when his foot slipped on the top step of the truck. He fell to the ground, landed on his left hip and elbow. The employee was hospitalized with a fractured hip/femur.

A security employee was responding to an urgent call from staff regarding a violent patient. The employee tripped and fell on the floor outside of the stairwell. The employee sustained a closed head injury, contusion of the cerebrum without loss of consciousness, and a closed fracture of the distal end of the right radius.

A security employee was holstering her firearm when the gun discharged a bullet into her right leg. The employee was hospitalized.

A temporary employee was testing an electrical starter motor. He was placing tape on the starter while the breaker was not engaged, but the starter sent an arc flash that burned his hands and stomach.

An employee was walking on a sidewalk and stubbed his toe on an elevated portion of concrete, causing him to trip and fall. The employee's right knee was dislocated.