American Sugar Refining, Inc.

An employee was using a motorized chain hoist to lift a pump weighing 600 to 700 pounds onto a working table. The hoist, which weighed approximately 100 pounds, fell from an overhead crane onto the employee s fingers, resulting in a finger amputation.

An employee was clearing a blockage of sugar when his finger contacted a moving screw conveyor. The employee's fingertip was amputated. The conveyor was not locked out at the time.

An employee became overheated and lost consciousness while prepping a railroad car to bulk load sugar onto it. The employee suffered from heat stroke/heat exhaustion/heat stress.

An employee was supporting a shaft that was in a vice during repairs when the shaft fell through the vice, hitting and partially amputating the employee's left ring finger.

An employee fell from the top of a tanker truck to the ground, breaking an ankle.

On December 26, 2023, an employee went out to the parking lot to troubleshoot the starter of an SUV. The employee was underneath the vehicle when it started and moved and the employee's middle back area was caught under the front passenger-side tire. The employee sustained a fractured collar bone.

An employee was parking at a patient's home and exited the van to manually open the garage door. The van began rolling backward and rolled over the employee's right leg. She was hospitalized with a fractured leg.

A driver exited their truck so they could provide service for a customer when the truck began to roll away. The driver went to re-enter the truck but fell and was struck by the rear driver-side tire. The employee sustained fractures to their leg and foot.

An employee had been operating a yard tractor. He parked the vehicle and was exiting when the vehicle began to roll, causing him to fall. The employee's hand was then run over by the yard tractor, resulting in fractures to multiple fingers. The employee was hospitalized.

An employee was checking for a leak in the air brake system of a semi-truck. The employee had removed the brake chamber when the truck rolled back. One of the tires pinned the employee's right hip against the ground.

An employee was adjusting the flat scratcher of a sweep cultivator when the metal tube of the scratcher slid down and caught the tip of the employee's left thumb between the pipe and C-clamp. The employee sustained a left thumb tip amputation.

A crew was building a scaffold inside a furnace. An employee was stabilizing the mudsill and jack as a 10-foot scaffold leg was being connected. The scaffold leg came in contact with the furnace wall, causing a piece of refractory brick to fall. It struck the right side of the employee's mid-back, causing a contusion.

Employees were reinstalling the frame of a mechanical guard onto a raw sugar mixer. A chain fall was used to position the frame so it's weight was resting on the lower pedestal. The chain block was then unhooked, and an employee used a hammer to position the frame so the top bolt holes would be aligned. The bottom of the frame slipped off the pedestal and the frame fell two feet down onto the employee's right arm causing fractures to the radius and ulna.

An employee was tasked with identifying a conveyor system failure. When the employee opened the conveyor, a flash fire occurred. The employee sustained burns to the hands and face and was hospitalized.

An employee was operating package filling equipment when he attempted to loosen clumped sugar in the equipment piping and injured his right hand. He was hospitalized with fractures to four fingers on his right hand.

A driver was exiting his vehicle outside the plant gate when his foot slipped on the top step of the truck. He fell to the ground, landed on his left hip and elbow. The employee was hospitalized with a fractured hip/femur.

A security employee was responding to an urgent call from staff regarding a violent patient. The employee tripped and fell on the floor outside of the stairwell. The employee sustained a closed head injury, contusion of the cerebrum without loss of consciousness, and a closed fracture of the distal end of the right radius.

A security employee was holstering her firearm when the gun discharged a bullet into her right leg. The employee was hospitalized.

A temporary employee was testing an electrical starter motor. He was placing tape on the starter while the breaker was not engaged, but the starter sent an arc flash that burned his hands and stomach.

An employee was walking on a sidewalk and stubbed his toe on an elevated portion of concrete, causing him to trip and fall. The employee's right knee was dislocated.