BEALE AFB, CALIFORNIA—
All Power Inc.
Direct exposure to electricity, unspecified · Second degree electrical burns
At a glance
Federal OSHA recorded a severe workplace injury at All Power Inc., B Street, BEALE AFB, CALIFORNIA 95903 on — Second degree electrical burns, affecting the arm(s), unspecified.
Watch All Power Inc. — free
Get an email when a new federal OSHA severe-injury report for All Power Inc. is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was pulling tape through an underground PVC electrical conduit to measure the conduit length. The tape contacted some moisture that created an arc flash when it came in contact with the energized switchgear. The employee suffered second degree burns on both arms. Proper PPE was not worn at the time of the incident.
Similar incidents · Same event type
DOTHAN, ALABAMA—
Bob Woodall Air Care Systems, Inc.
An employee was installing a 15-amp breaker in an electrical panel when a 12-gauge ground wire touched the positive busbar of the panel, resulting in an arc flash. The employee sustained a second-degree burn to their left hand.
KENNEDY SPACE CENTER, FLORIDA—
Amentum Spaceport LLC
An employee was repairing an HVAC system in the drop tile ceiling of a conference room when they were shocked, causing them to fall from the ladder. The employee sustained burns to their right middle and ring fingers.
NEWELL, WEST VIRGINIA—
Marsh Bellofram Corporation
An employee was replacing a contactor inside an electrical panel attached directly to a press. The press itself was receiving power from another main panel. After replacing the contactor, the employee flipped the switch and an arc flash occurred, burning the employee's elbow, bicep, and neck.
JACKSONVILLE, FLORIDA—
Heart Utilities of Jacksonville, Inc.
An employee was attempting to switch a medium-voltage primary cable and install a 200-amp fuse barrel. The employee contacted the bottom of the switch gear cradle for the fuse barrel, causing an arc blast. The electricity entered the employee s left hand and exited his big toes, resulting in electric shock and burns to the left hand, arm, shoulder, and both feet. The employee was hospitalized.
CARRABELLE, FLORIDA—
Duke Energy Florida, LLC
On December 6, 2023, an employee of Duke Energy was working on a single-phase 120-/240-volt parallel service re-tap when a secondary flash occurred in an underground service. The employee suffered a second-degree burn to the face and was hospitalized.
More severe injuries in this industry (NAICS 335311)
LAUREL, MISSISSIPPI—
Howard Industries Inc.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
LAUREL, MISSISSIPPI—
Howard Industries Inc.
An employee was troubleshooting a machine. He was investigating a slipping belt when it caught his left hand and pulled it into a pulley, partially amputating the tip of his thumb.
LAUREL, MISSISSIPPI—
Howard Industries, Inc.
An employee was tilting a radiator in a fixture. The radiator moved in the fixture and crushed the employee's left index fingertip, causing an amputation.
SHARON, PENNSYLVANIA—
Sunbelt Solomon Services, LLC
An employee installed a busbar on a coil for a winding machine. The busbar hit a tension bar, causing his left ring finger to get caught between the coil and the tension bar, which pulled in the employee's glove and resulted in a medical fingertip amputation. The machine was guarded at the time.
WASHINGTON, MISSOURI—
WEG Transformers USA
An employee was operating a wire winding machine when their clothing was caught in a rotating component, pulling them into the equipment. The employee's right arm was fractured.
More severe injuries in CALIFORNIA
LOS ANGELES, CALIFORNIA—
Department of Justice - USMS
The injured employee was assisting a Department of Homeland Security (DHS) enforcement operation. During an apprehension, officers returned fire at a subject and struck the employee with a bullet. The employee sustained a gunshot wound to their right hand.
LEMOORE NAVAL AIR STATION, CALIFORNIA—
M1 Support Services
The injured employee was assisting in the disassembly phase after a radar array had been lowered and secured. The crew began removing load bearing pins from an overhead crane to free the radome. A load bearing pin was stuck. The injured employee went to remove the pin manually as a second team member applied pressure from the opposite side. The pin unexpectedly released and struck the injured employee s right thumb, resulting in partial amputation of the distal phalanx including an open distal phalanx fracture and nail bed laceration.
SAN DIEGO, CALIFORNIA—
Dept. of Defense - USN
An employee was working on an electrical panel in a mechanical room when an arc flash occurred. The employee suffered burns.
SAN YSIDRO, CALIFORNIA—
Dept. of Homeland Security - CBP
At about 3:10 p.m. on October 3, 2025, an employee was inspecting a car. Two dogs that had been in another car were leashed and tethered to a bollard. As the employee inspected the first car along with a narcotics detection dog, one of the other dogs came loose and attacked the narcotics dog. The employee was separating the dogs when the other dog bit his left ring finger. The last joint of the finger was injured and part of it was bitten off.
EL CAJON, CALIFORNIA—
Sycuan Casino Resort
An employee was preparing a bundle of green onions for chopping. While holding the bundle in his left hand, he made his first cut using a 9-inch kitchen knife held in his right hand. The knife contacted the tip of his left thumb, resulting in an amputation of approximately 0.5 inches of the thumb that required hospitalization.