Exposure to environmental heat · Heat exhaustion, prostration
At a glance
Federal OSHA recorded a severe workplace injury
at DC Alabama, Inc., 1940 Ohio Ferry Road, MOUNT MEIGS, ALABAMA 36057
on — Heat exhaustion, prostration, affecting the bODY SYSTEMS.
Final narrative
On July 11, 2018, an employee was in the locker room after working near an extremely hot smelting furnace when he became disoriented and experienced nausea and fatigue. He was hospitalized for heat exhaustion.
An employee was performing finishing work on a residential driveway when they began to experience body cramps and were hospitalized for heat stress and dehydration.
An agent was participating in SWAT team selection and was performing various physical fitness skills including running and exercise intervals. The agent experienced dehydration and a muscular injury that required hospitalization.
On September 26, 2023, an employee was delivering packages when he began to feel ill with a pain in his side. He was hospitalized for heat exhaustion and dehydration.
More severe injuries in this industry (NAICS 331419)
An employee was performing maintenance on the second level of a silo. While they were making sure the belt pulley were not seized up, the belt was powered on, causing the employee's finger to get caught in the sheave. Their left little finger was partially amputated.
An employee was operating a table saw to cut pieces of lumber measuring 2x2x36 inches. The blade contacted the employee's left thumb, cutting half of the distal phalange bone and amputating the thumb tip along the bottom of the fingernail.
A temporary employee was wrapping a chain around a 2,000-pound block of metal, located on the ground. The block tipped over and crushed his right foot. He was hospitalized, requiring surgery.
An employee was observing the clean-up process of a spilled ladle. As the employee was walking away from an area of cooling metal, there was an eruption due to molten metal reacting with water. The employee fell forward, attempted to catch himself, and his right hand touched the molten metal resulting in burns to the little fingertip and middle finger.
An employee was helping unload a skid steer off a truck skip. While positioned with his left foot on the skid steer's step and his right foot on the tire, he was helping unhook the chains from the truck skip and slipped and fell backward, landing on the rear rail of the truck skip. He suffered six broken ribs and a flail chest injury.
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.