Other fall to lower level less than 6 feet · Dislocation of joints
At a glance
Federal OSHA recorded a severe workplace injury
at Northeast Prestressed Products LLC, Highway Project, EAST BUTLER, PENNSYLVANIA 16029
on — Dislocation of joints, affecting the finger(s), fingernail(s), unspecified.
Final narrative
An employee was delivering concrete beams to a construction project along a highway. During the unloading process, the employee was on the tractor when the employee lost footing and fell approximately 4 feet to the ground. The employee suffered bruised ribs and a dislocated finger, requiring hospitalization.
An employee was reading a tension meter attached to a sling. The sling jumped and contacted the employee's left thumb, resulting in a partial amputation.
On June 16, 2020, at approximately 5:00 PM, an employee reached to use controls to lower a hydraulic part of a trailer. The truck was on a hill and the unmovable part of the trailer moved and pinched his forearm against a concrete beam. He was hospitalized with injury to the right forearm.
Two steel beams were being set into place on dunnage. An employee was placing pads under the bearing points when a beam struck the employee's left wrist, fracturing it and requiring hospitalization.
An employee was finalizing a load for transport on a flatbed trailer. When finished, the employee used a chain to descend to the ground. The opposite end of the chain was not connected to anything and the employee fell approximately 10 feet to the ground, suffering a fractured pelvis.
On September 27, 2016, an employee was unhooking the safety chain from the hauling trailer when the truck driver started to pull ahead. The employee's right-hand middle finger was pinched and amputated between the safety chain and the trailer's hitch.
An employee was climbing a step ladder while carrying a 3-foot piece of conduit. As he went to reposition his feet on the ladder by pivoting, he slipped and fell from the third rung of a 6-foot ladder. The employee sustained fractures to the left femur, right elbow, and right ring finger.
An employee was descending a 4-step maintenance stand when she missed the bottom step and fell to the hangar floor. The employee suffered a left hip fracture.
An employee stopped a belt and was going to check it for missing packages. She fell backward 3-4 feet from an elevated platform and sustained a broken right arm.
An employee had just finished a routine concrete pour and was ascending the ladder to clean the concrete mixer truck. The employee lost their grip and fell approximately 2-3 feet, contacting the truck's bumper. The employee suffered rib fractures and a punctured lung.
An employee was performing duties as an expeditor. After opening the dock door, the employee scanned the barcode on the door of the truck and placed one foot on the truck and one foot on the dock. The truck drove out of the stall, causing the employee to fall 4 feet off the dock onto the concrete. The employee sustained fractures to the right side of the pelvis, elbow, and a left ring fingertip as well as injuries to the right wrist and bruising to the back and stomach.
More severe injuries in this industry (NAICS 327390)
An employee was stacking concrete blocks for a concrete bunker. As a block was swinging into place, the employee's left leg was pinched between two blocks, resulting in injuries to his left heel and lower leg.
An employee was patching precast concrete. He fell from a concrete wall support to the ground due to wind. He was hospitalized with fractures to his left ankle and right knee.
An employee was cutting wood on a table saw when the wood got jammed. While clearing the jam, the wood moved forward and his left index and middle fingertips were amputated.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.