KANSAS CITY, MISSOURI—
FORD MOTOR CO. - KANSAS CITY ASSEMBLY PLANT
Entangled in other object or equipment · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at FORD MOTOR CO. - KANSAS CITY ASSEMBLY PLANT, U.S. HIGHWAY 69, KANSAS CITY, MISSOURI 64119 on — Fractures, affecting the hip(s).
Watch Ford Motor CO. - Kansas City Assembly Plant — free
Get an email when a new federal OSHA severe-injury report for Ford Motor CO. - Kansas City Assembly Plant is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was hanging up a DC electric gun. The employee's foot got tangled up in the gun's power cord, and the resulting twisting/pulling motion caused a broken left hip.
Similar incidents · Same event type
ATLANTA, GEORGIA—
ATB Renovations, Inc.
On November 9, 2023, an employee was removing plywood from the west face of a basement level buck hoist to prepare to dismantle one of the cabs. When the employee pulled on the plywood, it fell and pulled a rope that partially amputated the employee's thumb.
SAN ANTONIO, TEXAS—
Systems MEC LLC
An employee was holding a rigging line and assisting in the removal of an old light pole from its base. When the load was lifted by a forklift, it shifted. The tag line lifted the employee off the ground and propelled him through the air. The employee landed on the ground and sustained back fractures.
PORT SAINT LUCIE, FLORIDA—
Liberty Tire Recycling, LLC
An employee was performing maintenance on a bucket truck when his right hand became caught in some rope, causing amputations to three fingers down to the first knuckle.
GREELEY, COLORADO—
Hensel Phelps Construction Co.
An employee was conducting a fall rescue demonstration. A 165-pound demonstration dummy was released from a height, putting tension on the lanyard. The employee's left hand, little finger, and thumb were caught in the wire rope lanyard, resulting in a medical amputation of the left little finger as well as lacerations to the left thumb.
MENTONE, TEXAS—
Ace Fluid Solutions
An employee was using a crank and cable to lower a light tower due to windy conditions. The light shaft became hung up and released the tension in the cable, which wrapped around the employee's left hand, resulting in amputations of three fingers.
More severe injuries in this industry (NAICS 336111)
AUSTIN, TEXAS—
Tesla Giga Factory
An employee was using a battery-powered torque tool to fasten a bolt. The tool was activated and the socket of the tool rotated and pulled in their gloved left hand. The employee sustained a left index fingertip amputation.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was inspecting a casted part that weighed 330 pounds. The part fell from a lift assist onto the employee, striking his upper right arm and head. He suffered burns to the upper right arm and was hospitalized.
THE COLONY, TEXAS—
Tesla Distribution Center
An employee was reaching to hook her harness into a lanyard and began to experience abdominal pain. The employee sustained an umbilical hernia.
AUSTIN, TEXAS—
Tesla, Inc.
On June 4, 2025, an employee was skimming molten aluminum when it dripped down from the skimming spoon onto the employee's left pant leg, burning the top of their left foot. The employee was hospitalized and required surgery.
SANDUSKY, OHIO—
Ventra Sandusky LLC
On June 3, 2025, the injured employee was setting a mold with a co-worker when the mold was displaced and caught their right hand against the stop block. The employee sustained a fracture and partial amputation of their middle finger.
More severe injuries in MISSOURI
SAINT LOUIS, MISSOURI—
WADDELL CONCRETE INC.
An employee was readjusting a safety hook to remove hardware from gang forms when his feet slipped. He fell to the ground, resulting in a broken left arm and wrist.
MOUNT VERNON, MISSOURI—
Dollar Tree
An employee was on a step ladder in a store aisle, making room on shelving for merchandise. She fell from the step ladder to the floor, suffering two fractures in her left leg. She was hospitalized, requiring surgery.
CHESTERFIELD, MISSOURI—
Corrigan Brothers Inc
An employee was closing the side cargo door to a company van. The tip of his finger got caught between the door and the door jamb, resulting in a partial amputation.
MOBERLY, MISSOURI—
Plumb Supply Company
An employee lost his footing while climbing an inclined ladder. He stumbled down one step and was able to stabilize himself by holding the railing and twisting his body, but he suffered an internal abdominal injury and was hospitalized.
SPRINGFIELD, MISSOURI—
JRI INDUSTRIES
An employee was manipulating dies on a brake press. The press caught and crushed the employee's right forearm, resulting in hospitalization.