Caught in running equipment or machinery during maintenance, cleaning · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Exterior Specialties, Inc., 1621 Lake Ella Dr., TALLAHASSEE, FLORIDA 32303
on — Amputations, affecting the finger(s), fingernail(s), unspecified.
Final narrative
On June 19, 2019, an employee was operating a machine that carries shingles onto a roof when the belt came off. As he attempted to set the belt onto the machine's pulley, his right index finger was caught between the pulley and the belt, resulting in an amputation of his right index finger without bone loss. The machine was energized at the time of the incident.
On or about August 2, 2016, at approximately 3:30 p.m., an employee was helping to install roofing underlayment when he stepped on wet membrane material and slid off the roof, falling more than 12 feet to the ground below and lacerating his head and tongue.
Two employees were repairing the hydraulic engagement pins on a rented front-end wheel loader. The machine controls were activated to move the attachment pins and an employee's finger was caught between the pins and the bushings. Their right index finger was partially amputated.
An employee was cleaning the conveyor on a piece of equipment when they slipped and their right hand was pulled into the chain sprocket. The employee's fifth fingertip was amputated.
An employee was throwing blankets onto a blanket folding and stacking machine. A blanket got stuck in the machine and she attempted to remove it when the machine contacted her right little finger, resulting in a fingertip amputation.
More severe injuries in this industry (NAICS 238170)
An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.
An employee was on an A-frame ladder, installing a drip edge as part of a gutter installation. The employee fell to the ground, suffered a head laceration and a concussion, and was hospitalized.
An employee was on scaffolding when they fell into a 1-foot gap between the scaffolding and a building. He fell 8-9 feet to the ground, sustaining head injuries and fractures to their arm(s). The employee was hospitalized.
An employee was removing stucco from the side of a wall when the ceiling collapsed. The employee jumped out of the way and began descending the side of the scaffold when they fell to the ground. The employee sustained a fractured right wrist.
An employee was on a straight ladder approximately 6-7 feet above the ground to set straps to hold a truss to the foundation of a house. He reached for the next strap and lost his balance, falling from the ladder and landing on his feet on the floor. The employee sustained one fractured foot and one bruised foot.
An employee was helping a coworker transport a tall palm tree with a mini skid steer. The employee was severely shocked by a high-voltage electrical wire above the ground.
An employee was retrieving a Christmas tree from a shelf using a ladder. He missed a step and fell to the concrete floor. He sustained injury to his head and wrist.
An employee was operating an agricultural tractor during sugarcane harvesting. The employee sustained a lumbar sprain due to vibration or motion from the tractor.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.