Exposure to environmental heat · Effects of heat and light, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at TPC Group LLC, 2066 Goodyear Drive, HOUSTON, TEXAS 77017
on — Effects of heat and light, unspecified, affecting the bODY SYSTEMS.
Final narrative
An employee suffered a heat-related injury, becoming nauseous and fatigued, while walking throughout the unit checking valves and preparing the unit for start up.
An employee was struck by a utility vehicle that was backing into a shop to load a piece of equipment. The employee sustained left forearm fractures, a left patellar fracture, spinal fractures, and a cerebral hemorrhage.
An employee was performing finishing work on a residential driveway when they began to experience body cramps and were hospitalized for heat stress and dehydration.
An agent was participating in SWAT team selection and was performing various physical fitness skills including running and exercise intervals. The agent experienced dehydration and a muscular injury that required hospitalization.
On September 26, 2023, an employee was delivering packages when he began to feel ill with a pain in his side. He was hospitalized for heat exhaustion and dehydration.
More severe injuries in this industry (NAICS 325110)
An employee was applying pressure to a tank car loaded with caustic soda solution for post-load leak testing. He twisted the valve plug to check it for leaks when it broke free, releasing the caustic soda solution through the opening. The employee suffered chemical burns to both eyes and to his respiratory tract.
Employees were setting up an 8-inch sewer PVC pipe line. An employee was removing/rolling a scrap PVC pipe off the conveyor when their little fingertip was crushed between the end of the PVC pipe and the post for the overhead bus stop guard (fixed guard). The employee was hospitalized and required surgery.
An employee was walking by an equipment battery (tank battery) when a leak occurred around a heater that caused a flash fire. He was wearing flame-resistant clothing and sustained burns to his palms and back.
Two employees were removing a recirculation pump from service at an evaporator. They were disconnecting pump flanges and couplings from the motor when boiling water burst out from the system. Both employees sustained second-degree burns to the chest, stomach, and arms.
On December 9, 2024, an employee was cleaning out a mixtruder. While he was retrieving some residual pieces of silicone left inside, its rotating blades caught the fingers of his right hand resulting in amputation of all four fingers. The thumb was left intact.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.