Statz Bros., Inc.

An employee was leading cows toward the milk parlor when a cow backed up, crushing the employee's right index finger against a metal bar of the staging area. The finger was partially amputated.

An employee was extinguishing a fire beneath a combine. The combine driver did not know the employee was beneath the combine and ran over the employee, who suffered internal bleeding in the right leg and a spinal injury.

An employee was drying and finishing vehicles when a vehicle door closed on their left middle fingertip and amputated it.

An employee was climbing down from a tractor trailer bed when they lost their footing and grabbed onto the roll-up door to stop the fall. The roll-up door then fell onto the employee's hand, resulting in a hand fracture that required surgery.

An employee was attempting to remove a tarp from a flatbed trailer when the trailer handle struck the employee in the chest, resulting in two broken ribs and a punctured lung.

An employee was near a backhoe while the operator was getting a broom. The broom handle struck the lever that actuates the swing of the backhoe bucket. The bucket then struck the injured employee, pinning him to the outrigger. The employee suffered crush injuries to the chest.

The injured employee was being trained on loading trucks in the load out bay. The injured employee and his supervisor climbed the stairs that run parallel to the truck and trailer, walked to the upper platform used for observation and sample taking, and saw that the lid of the grain trailer was closed. The employees began working to open the lid which appeared to be stuck due to cold weather. The injured employee pulled on one of the pivot arms that connect the lid to the main body of the trailer. As the lid began to open, the employee s right hand slipped down on the pivot arm and his index finger was caught between the pivot arm and the base of the pivot arm. The employee s right index finger was fractured and three nerves were severed. The employee was hospitalized.

Employees were stripping parts off an old pivot. An employee was standing on the ground, helping others make sure that the parts all came off the pivot. The pivot span was elevated when the base beam broke free on one side. This shifted the weight of the span, causing it to roll off the loader on its side. When the span came down, the support rod caught the employee's back as he went to turn and run away from it. It pushed him to the ground. He suffered a back fracture, along with a broken bone in his foot, and was hospitalized.

An employee was walking through the hospital pen and a cow struck him with her head. The employee sustained an orbital fracture.

An employee was working in a holding pen, using a crowd gate to herd cows into milking stalls. She was moving to beat the crowd gate to a manhole, but the gate moved and struck the employee. The employee was hospitalized with two fractured processes in her lower vertebrae.

Three maintenance employees were working on chemical lines feeding into a large above ground wastewater treatment tank. Sodium hydroxide and sulfuric acid reacted in a floor drain and the chemicals sprayed onto the three employees. One employee was taken to the hospital for burns to his eyes.

An employee was removing a pin from a metal gate to let cows out of a parlor. The gate moved and his left middle finger was caught in the pin hole. The employee's finger was partially amputated.

The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.

An employee was using a vertical band saw to cut a thick piece of rubber material. While being cut, the material shifted, causing the employee s right hand to contact the moving blade. The employee's thumb was amputated below the knuckle. The employee was hospitalized, undergoing surgery.

A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.

An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.

An employee was unloading a truck for a delivery job. While moving boxes in the truck, the employee tripped over a pallet and fell out of the truck to the ground, resulting in four broken ribs.