Pedestrian struck by vehicle backing up in work zone · Fractures and other injuries, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Lehigh Hanson, 200 Delaware Avenue, PALMERTON, PENNSYLVANIA 18071
on — Fractures and other injuries, unspecified, affecting the multiple body parts, unspecified.
Watch Lehigh Hanson — freeGet an email when a new federal OSHA severe-injury report for Lehigh Hanson is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was flagging drivers in a work zone on a public highway. He was struck by a spray truck that was moving in reverse while applying tar during a tar and chip paving operation. The employee suffered trauma to the left side, broken vertebrae, a punctured lung, and trauma to internal organs.
HospitalizedMultiple body parts, unspecifiedTruck-motorized freight hauling and utility, n.e.c
A temporary employee was setting up a roadway construction zone. They were dropping cones from the back of a pickup truck. One of the cones fell and the employee exited the pickup truck to straighten the cone. The pickup truck then backed up and struck the employee causing rib and pelvis fractures.
An employee was walking backward, cleaning a roadway with a flat shovel. A rubber-tracked excavator, also backing up, approached the employee. Its tracks caught the employee's pants, which caused the employee to fall forward. The machine then caught the edge of the employee's foot. The employee suffered bruising to both feet and an ankle, as well as a bone chip on the front of the right heel.
An employee was directing traffic and performing clean-up activities at a site they were preparing for asphalt pavement. The employee was struck by a skid loader that was traveling in reverse, resulting in fractures to the left leg and hip. The employee was hospitalized.
A traffic control employee was assisting a homeowner who was backing out of their driveway when they were struck by an excavator traveling in reverse. The employee sustained a hip and foot fracture.
An employee was flagging for traffic control when he was struck by a truck that was backing up. The employee sustained a punctured lung and broken ribs.
More severe injuries in this industry (NAICS 237310)
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
An employee was cleaning out an inlet pipe in a stormwater structure. The employee stepped back, fell into the pipe, and landed on concrete 13 feet below, at the bottom of the structure. He suffered a broken back.
A concrete batch plant operator was assisting with clearing spoil piles using a skid steer. The skid steer backed into a stationary screen plant. The employee's left little finger was crushed between the controls of the skid steer and the screen plant, resulting in a fracture and laceration. The employee's finger was surgically amputated.
An employee was operating a roller and paving a small pathway next to a pavilion. The ground was on a slight pitch, causing him to reach up toward the roll cage to stabilize himself. His right fifth finger was pinched between the roll cage and the rafter of the pavilion. The employee sustained a partial degloving injury with partial traumatic amputation.
An employee was working with paving equipment and heard a noise on the opposite side of the machine he was working on. When the machine stopped, the employee went to the opposite side and crouched down to investigate the noise. A mini track loader backed up and drove over the employee's leg. The employee sustained fractures to their lower leg, ankle, and foot.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.