Estes Express Line

On January 5, 2023, an employee was standing on a dock when they were struck by a forklift, resulting in fractures to both their legs and hips that required surgery.

An employee was operating a forklift when the forklift struck a dock wall, resulting in a fractured forearm.

On November 4, 2020, an employee was operating a forklift and struck the side of a trailer. The employee fell off the forklift and their legs were pinned underneath the forklift. The employee was hospitalized for leg fractures.

An employee was struck by a forklift while working on the loading dock. The employee was hospitalized for a right ankle fracture.

An employee was walking back to her workstation. A forklift reversed a short distance, then completed a U-turn and struck her, running over her lower extremities. She was hospitalized with a broken ankle.

An employee was training on a jockey truck. Upon stepping out of the truck, the employee was struck by a rubber tire gantry crane, resulting in amputations of the right leg above the knee and left leg below the knee.

An employee was standing at the rear of a double pallet jack. Another double jack approached, and the employee's lower leg was caught between the two pieces of equipment. He suffered a broken tibia and fibula.

An employee was unloading large material bags on a loading dock. A forklift tine pinned the employee's foot against a pallet, causing the employee to fall and suffer a broken ankle.

An employee was pushing a container when they were struck by a forklift. The employee sustained a left leg fracture.

An employee had dumped a load of hot mix (tar) and was cleaning the interior walls of a belly dump trailer onsite. The employee was scraping the walls of the trailer when the doors articulated, breaking the securement pin and pinching the employee's legs. The employee sustained crushing injuries and severed tendons and arteries to both legs and was hospitalized.

An employee was transferring sulfuric acid into a customer's tank. They connected the transfer hose to the receiving tank and attached the compressed air line used to pressurize the trailer. An air valve opened during unloading and a small amount of sulfuric acid got under the employee's face shield and onto their face. The employee suffered third-degree chemical burns to their face, right ear, and chest.

An employee was working to adjust a misfed pallet board that was entering the pallet board collection point. His left middle fingertip became caught between the board he was adjusting and other boards already stacked in the collection area. This resulted in amputation of the fingertip.

On July 22, 2025, at approximately 4:30 a.m. after the previous day's shift, an employee was hospitalized with a kidney injury caused by heat-related illness. The employee had worked several consecutive days delivering packages in high outdoor heat and humidity without cooling gear.

On July 18, 2025, an employee was tarping a load on a flatbed trailer in the yard. He fell approximately 13 feet off the loaded trailer and landed face-down on a gravel lot. The employee sustained facial cuts, abrasions, scrapes, fractures to their face, as well as several fractured ribs. He was hospitalized.

An employee tripped over a stool and fell on the floor, resulting in a left displaced mid-cervical femoral neck fracture.

An employee was installing fence posts when they stepped into a recently dug hole that was not visible due to rainfall. The employee's leg was fractured.

An employee assisted in cleaning material from a conveyor pit. After the pit was cleaned, the employee proceeded to replace metal safety plates to ensure other employees did not fall into the pit. While replacing one of the last plates, the employee mis-stepped and fell approximately 5 feet into the pit. The employee was hospitalized with back/side bruising, elbow bruising, bone bruises, and/or fractured ribs.

An employee was inspecting a breaker box and turning on/off a circuit breaker when he was electrocuted.

An employee was walking on the sidewalk. When they stepped off the curb, they fell to the ground, resulting in fractures to their tibia, fibula, and a metatarsal.