Struck by other falling powered vehicle · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Saiia Construction Co LLC., 4400 Lewisburg Road, BIRMINGHAM, ALABAMA 35207
on — Amputations, affecting the finger(s), fingernail(s), unspecified.
Final narrative
An employee was operating a zero-turn lawnmower when it ran over a pipe, lodging the pipe between the deck and the ground. As he was trying to remove the pipe, the lawnmower fell and struck his finger. He suffered an amputation.
An employee was operating a bulldozer in a pond where hydrogen sulfide had been detected by monitoring devices. The employee was found unconscious and required hospitalization. Personal protective equipment was not worn at the time.
An employee was repairing the right rear tire of a tractor in a customer's yard. While removing the cribbing, the tractor slipped and came down on him. The tire was not yet inflated and the employee was pinned by the tractor. The employee sustained crush injuries to the hip, pelvis, and tailbone including several fractures to the pelvis.
An employee was working underneath a vehicle that was suspended on two jack stands when the vehicle frame broke. The vehicle fell onto the employee, resulting in a back fracture, rib fractures, and a punctured lung.
On June 17, 2023, an employee was checking a tire for leak. As he released the air brake, the semi-truck fell from the jack onto the employee's right arm and rolled forward. The employee sustained an arm injury.
A forklift was unloading a pallet jack from a rental truck when the pallet jack fell off the raised forks and struck an employee as she was working to steady the load. She sustained a right thigh fracture along with scrapes and bruises.
More severe injuries in this industry (NAICS 237990)
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
An employee was standing on an extension ladder, using a torquing tool to remove bolts that secured blades to a rotor. When the torquing tool activated, its reaction arm came around and pinched the employee's right middle finger against a lifting eye. His fingertip was amputated.
Employees were securing the fuel line of an outboard motor in preparation for removing the motor from a small vessel located in the equipment yard. A gasoline-related fire occurred and one employee sustained burns to both hands and forearms.
A marine diver/construction worker was working underwater, using a hydraulic dredge to clear sediment away from the base of a dam. The dredge's suction nozzle began migrating toward him, and then pulled in his right hand and forearm. He sustained compartment syndrome in the hand and forearm.
An employee was standing on a sheet of -inch by 4-foot by 8-foot plywood on top of a rebar mat, supervising his crew. As he was moving to alert the crew to an incoming overhead load, he stepped off the plywood and his left foot slipped through the rebar mat and landed on the rebar mat below. His left ankle was broken and dislocated.
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.