U. S. Department of Army

On the morning of July 24, 2025, an employee was conducting synthesis of a highly toxic experimental chemical (nerve agent) in a chemical fume hood. The operation was completed at approximately 11:30 AM. The employee was exposed to the chemical and began experiencing symptoms of illness/poisoning around 1:30 PM and was hospitalized.

On March 10, 2025, an employee was using a chainsaw to cut down a tree at a golf course. When he cut a branch on the tree, it fell to the ground, landing straight up and leaning on the main trunk of the tree. A part of the branch, at the top, broke off and fell about 15 feet. It struck the employee in the head and knocked him into some brush. He suffered a head laceration, as well as some concussion-like symptoms, and was hospitalized.

An employee was participating in the running portion of a physical examination when they collapsed due to heat exhaustion.

An employee mis-stepped while getting off a tour bus. The impact onto the ground surface caused a compound fracture to their leg requiring hospitalization.

An employee slipped on ice on a stairway, losing his balance and landing on concrete. His leg was broken.

An employee was delivering mail when they tripped on a curb and fell to the ground, resulting in a kneecap injury.

An employee was leaving work when they tripped over a curb in the parking lot and fell into a wall, resulting in a fractured left humerus.

A nurse was visiting the home of a patient for requested treatment. She tripped on her gown while going up the steps to the property, falling and fracturing her left femur.

An employee tripped on a step while entering a house. The employee suffered a broken right femur and was hospitalized, requiring surgery.

An employee was walking up an escalator that was out of service when they tripped on a step, fell, and suffered a closed fracture to the right femur as well as a dislocated right patella.

An employee was activating the sprinkler system at a sports complex following recent maintenance to repair leaky pumps. When the system was activated, a section of newly installed 3-inch schedule 80 PVC pipe struck the employee, who lost consciousness. The employee suffered a broken jaw and a concussion.

An employee was ascending a flight of stairs after exiting their vehicle in an adjacent employee parking lot. The employee stepped to the right to avoid another employee on the left who was descending the stairs. The employee lost their balance and fell on the stairs. They were hospitalized with a laceration/abrasion to their chin, a fractured left humerus, and bruising to their left knee.

An employee was working on an electrical panel in a mechanical room when an arc flash occurred. The employee suffered burns.

At about 3:10 p.m. on October 3, 2025, an employee was inspecting a car. Two dogs that had been in another car were leashed and tethered to a bollard. As the employee inspected the first car along with a narcotics detection dog, one of the other dogs came loose and attacked the narcotics dog. The employee was separating the dogs when the other dog bit his left ring finger. The last joint of the finger was injured and part of it was bitten off.

An employee was climbing a fixed ladder to perform maintenance in an attic. While unlocking the attic entry, the employee fell from the ladder more than 10 feet to the concrete below. The employee suffered a fractured hip, pelvis, tail bone, arm, and elbow, resulting in hospitalization and surgery.

An employee was helping to lift the grating from a floor draining system when the grating slipped and landed on his hand, resulting in the amputation of his right middle finger at the first joint.

A casting machine jammed. An employee's hand was caught in the machine, where a belt line caught and amputated the tip of his finger.

During a workshop meeting in a hotel, an employee heard a drilling noise, so he walked outside to see what it was. An explosion occurred (possible gas line) and his face, ear, and hair were burned. He also fell and sustained a pelvic fracture.

An employee slipped on condensation on a walkway in a parking garage. She fell and suffered a closed fracture to the neck of the left femur.

An employee was using a tool to remove a rag from a roll on the tube mill. The roll pulled the tool and the employee's right hand into the roll, resulting in a partial amputation of the little finger and a fracture to the index finger.