Other fall to lower level 6 to 10 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at SIMFLO, LLC, 2605 I-27, LUBBOCK, TEXAS 79404
on — Fractures, affecting the chest, except internal location of diseases or disorders.
Final narrative
At about 3:00 p.m. on October 28, 2021, an employee was on a work platform, which had been raised by a forklift 8-10 feet off the floor so he could access the control box for an overhead door that had stopped working. A door on the platform swung open and the employee fell backward to the floor, landing on the back left side of his body. He suffered six broken ribs on the left side and was hospitalized.
HospitalizedChest, except internal location of diseases or disordersForklift, order picker, platform truck-powered
An employee was checking the taped hole he created on a shaft and was pulling the tail stock back on the lathe. The employee leaned over the machine and the lead screw caught his shirt, pulling him into the machine. As it pulled tighter, he was forced toward the machine, impacting his right shoulder. The employee suffered multiple fractures and torn tendons to right shoulder.
An employee was preparing a tank car for loading while chipping away solidified product in the manway opening of the tank car. A pressure noise within the tank car startled the employee, causing him to stumble backward and fall approximately 10 feet over the guard railing at the chemical loading rack to the ground. The employee suffered fractured vertebrae, a fractured right wrist and ankle, and a dislocated jaw.
An employee was installing an electrical tray remover from a ladder. As he was descending, his missed a step and fell 6-7 feet to the floor. The employee suffered a head injury.
Two employees were installing spray foam insulation in the attic of a new residential construction. The injured employee fell 8 feet from an A-frame ladder to the floor. The employee suffered lacerations, abrasions, and a head injury.
An employee was on a raised platform attaching wires to electrical boxes. The employee fell approximately 8 feet to the floor below and struck an exit sign on the way down, resulting in an injury to his face.
An employee was in a forklift man basket fixing a garage door opener when they fell approximately 8 feet to the concrete ground below. The employee suffered head and back injuries as well as kidney bruising.
More severe injuries in this industry (NAICS 333914)
An employee was completing a winding process involving installation of magnet wire into a stator. The final loop of the wire wrapped around the employee's left little finger and pulled it into the stator, resulting in an amputation to the finger below the first joint (in the area of the fingernail).
An employee was on the roof removing a hatch door from a super heater by pulling it. The employee then stepped over a pipe on the roof and felt pain in his back that prevented him from walking or standing. He was hospitalized for a back injury.
An employee was using a handheld, electric-powered sander to sand the edge off a 2x4 handheld sanding block to make it rounder. The sander caught the tip of his thumb, resulting in a fingertip amputation.
An employee was checking the taped hole he created on a shaft and was pulling the tail stock back on the lathe. The employee leaned over the machine and the lead screw caught his shirt, pulling him into the machine. As it pulled tighter, he was forced toward the machine, impacting his right shoulder. The employee suffered multiple fractures and torn tendons to right shoulder.
An employee was installing a blind flange onto a pump fluid end. The employee was pushing the flange into place when their left index finger was caught between the fluid end and the blind flange of the counterbore of the steel pump. The fingertip was amputated.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.