On December 7, 2021, a crane operator was tasked with relocating four lifting pad eyes from a pallet on the floor. The handling gear to be used was located on a handling gear rack. As the crane was hoisting a set of hook chains from the rack, the handling gear rack fell over onto a nearby employee, resulting in a fractured left femur.
HospitalizedThigh(s)Racks-garment and other
More severe injuries at Newport News Shipbuilding Division of Huntington Ingalls Industries
On October 16, 2024, an employee was installing a 2-inch by 6-inch pin in the eyelets of a large machinery door's cylinder and hinge. He was using a pry bar to raise the cylinder into position and confirming the alignment of the eyelet holes with his left index and middle fingers. The pry bar shifted, which caused the cylinder to drop onto his fingers. The employee's left index fingertip was amputated.
A temporary employee was using a hammer to remove loosened coupling bolts from the main shaft coupling in the shaft alley of a submarine. The hammer struck his left middle finger, causing an open fracture to the tuft of the last joint.
An employee was sanding a foundation fixture weighing approximately 400 pounds. The employee was working to rotate the fixture 90 degrees toward the ground in order to access the underlying edges. As he was maneuvering the foundation downward, it tipped over and a protruding appendage of the foundation pinned his pinky finger to the floor. The employee's finger was surgically amputated.
An employee was moving a piece of an I-beam for welding when it rolled off the cribbing. The employee went to catch it when it fell and crushed the employee's finger, resulting in a partial amputation.
An employee was helping to disassemble large reels used to store steel wire when a 264-pound flange from the reel fell over onto the employee's left leg. The employee sustained multiple fractures to their leg and ligament injuries to the lower leg.
The injured employee was putting away materials on the warehouse floor as a co-worker was pushing a pallet onto a nearby shelf. The pallet knocked another pallet forward, causing it to fall onto the injured employee's shoulders. The employee suffered fractures in their right and left knees and ankles.
Employees were moving a single man lift into a building and reclining the lift to position it to fit through the door. The lift shifted and fell, causing the employee to sustain fractures to the left tibia and fibula. The employee was hospitalized and had surgery.
An employee was moving a light tower so it could be hitched to a truck. He grabbed the tongue of the trailer hitch on the light tower to slide it to the left. The tongue jack fell off, causing the light tower tongue to drop on the employee's right hand. The employee's middle fingertip was amputated.
More severe injuries in this industry (NAICS 336611)
An employee was hooking up bundled tie-downs with a chain. While he was holding a hook, the other hook was unlocked. This caused the employee's hook to slide down and pinch his right index finger between the chain and the shackle. He suffered an amputation to the fingertip (without bone loss), as well as an open fracture.
An employee was preparing to bend a flat bar in a brake press. When the machine was jogged, the stock rotated up and crushed his left middle fingertip against the outer frame of the die. The fingertip was amputated.
An employee was cutting metal with a torch. A piece of metal struck the employee's left foot, causing multiple fractures to metatarsal(s). The employee was hospitalized.
An employee was descending a ladder carrying a bag of trash. He fell, landed on the ground about 10 feet below, and suffered fractures to his right hip and pelvis.
A building engineer was inspecting a generator. As he closed the generator enclosure door, his right ring finger was caught between the door and the door frame. The fingertip was amputated.
An employee was walking back to a carrier case with mail in her hand when she tripped over a tub. Her back overarched as she fell, resulting in a fractured back that required hospitalization.
An employee was driving a utility tractor rig when it struck the rear trailer of another utility tractor rig, which was traveling in the opposite direction. The glancing impact caused damage to the cab, and he sustained a laceration on right side of his face, a cervical fracture, two fractured left ribs, and a pelvic fracture. The employee was hospitalized.
An employee was washing an aircraft from a scissor lift when they fell to the floor. The employee sustained a back injury and lacerations to their head and neck.