Struck by swinging or slipping object, other than handheld, n.e.c. · Multiple traumatic injuries and disorders, n.e.c.
At a glance
Federal OSHA recorded a severe workplace injury
at Incipe, LLC d/b/a as Hawk Ford of Oak Lawn, 6100 W. 95th Street, OAK LAWN, ILLINOIS 60453
on — Multiple traumatic injuries and disorders, n.e.c., affecting the multiple head locations.
Final narrative
On January 13, 2022, an automobile was driven onto a four-post lift to raise the automobile in the air. A service technician engaged the Swing Air Jack in order to elevate the rear tires of the automobile above and off the lift. When the employee engaged the hydraulics to raise the automobile with the Swing Air Jack, the Swing Air Jack unexpectedly released horizontally and toward the employee who was struck in the face. The employee was rendered unconscious and was hospitalized for a concussion, brain bleed, and broken facial bones.
HospitalizedMultiple head locationsAutomobile lifts and hoists
A crew was pulling a 4-inch plastic gas pipe off a reel and straightening it for installation. The injured employee stepped up on the trailer to cut the last band holding the pipe in the coil on the reel. As he turned to step off the trailer, the end of the pipe rotated and sprung out of the cage surrounding the coil, striking the employee on the side of the head and knocking him off of the trailer into the roadway. The employee suffered head trauma that required hospitalization.
An employee and a co-worker were performing a pick inside a clear well. They rigged the skid pan that was full of broken concrete. When lifting, the load began to swing toward a wall. The employee tried to stop the skid pan from swinging and was struck by the pan, resulting in fractures to their left hip and wrist.
The employee had just completed refueling a lattice crane that was breaking up material and was winding the fuel hose back into the fuel truck when he was struck by the catwalk/stairs of the crane. The employee was hospitalized with a laceration to his backside, possible internal bleeding, and a broken hip.
An employee was fusing 10-inch black rubber utility pipes together using a pipe fusion machine and could not get the pipes to set correctly. The employee used a nylon strap attached to an excavator to lift one side of a pipe off a steel plate. As his hand was between two pipes, the pipes came back together, partially amputating two of his fingers.
An employee was lifting four bags of a lime blend weighing approximately 10,000 pounds using a crane. The load swung and pinned the employee against a structural I-beam, resulting in fractures to the hip and pelvis.
More severe injuries in this industry (NAICS 441110)
An employee was working underneath a vehicle when the vehicle began to roll and a tire caught the employee's left ear. The employee sustained a laceration and partial amputation of their ear, requiring hospitalization and surgery to reattach the ear.
A car was being backed out of a bay so that another car could pull into it. The car's brakes did not respond, and the car reversed quickly. The injured employee approached the car to stop it, and it pinned his right leg against a lift. The employee was hospitalized.
An employee was exiting the company shuttle van when his shoe became caught on the door of the vehicle, causing him to fall out of the van to the ground. The employee was hospitalized with a fractured hip that required surgery.
An employee was working to change the tires and brakes on a vehicle. He pulled the vehicle out of the bay. The brakes failed, and the car drifted backward into another bay where it pinned the injured employee against the arm of a vehicle lift. The injured employee sustained seven fractured ribs on his left side.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.