WAUSEON, OHIO—
Mahoney Foundries, Inc.
Fall through surface or existing opening 16 to 20 feet · Fractures and other injuries, n.e.c.
At a glance
Federal OSHA recorded a severe workplace injury at Mahoney Foundries, Inc., 225 E Linfoot St, WAUSEON, OHIO 43567 on — Fractures and other injuries, n.e.c., affecting the multiple trunk locations.
Final narrative
An employee was on a roof with contractors getting estimates for roof repairs. The employee fell through the roof, struck an air compressor during the fall, and landed on a wooden pallet and the concrete floor approximately 20 feet below. The employee sustained broken vertebrae and a punctured lung.
Similar incidents · Same event type
FERNANDINA BEACH, FLORIDA—
Lasting Impressions Enterprises, Inc.
On November 16, 2023, at around 3:30 p.m., a subcontracted employee was painting a door jam on a three-story house when he fell 20 feet through an opened elevator shaft to the floor below. The employee sustained fractured vertebrae that required hospitalization.
DALLAS, TEXAS—
GNP, Inc. Sheetmetal
Employees were removing and replacing skylights on a metal roof. The injured employee's lanyard became tangled and they fell through the skylight to the ground 16-18 feet below. The employee suffered fractures to the wrist, ribs, and hip.
BEAUMONT, TEXAS—
Perfectly Safe Systems
An employee was requested by a client to string wire on top of an auditorium. He used a boom lift to access a beam and then exited the boom lift to walk on the beam. He then stepped down on a drop ceiling, lost balance, and fell. The drop ceiling caved in and the employee fell 20 feet onto bleachers sustaining injury to his abdominal area and lower left leg. The employee was wearing a harness, but it was not connected to an anchoring point at the time of the fall.
PALMYRA, WISCONSIN—
The Scharine Group, Inc.
An employee was installing decking (steel grates) in a new construction steel framed building. The employees were working approximately 22' above the next lower level, which was a concrete ground floor. The decking was pre-cut with the floor opening prior to installation. Shortly after installing the floor opening, the employee fell through the floor opening, approximately 18' onto a section of metal ductwork, resulting in fractures to the skull, ribs, thorax, and lumbar vertebra, as well as an ear laceration.
TAYLOR, TEXAS—
BakerTriangle - Liberty Hill Office
An employee was taking measurements of an area for drywall when they stepped backward into a partially covered hole in the floor. The employee fell approximately 17 feet to the level below, sustaining a forehead fracture and avulsion, a right shoulder dislocation, a left forearm fracture, left knee tendon and meniscus tears, as well as multiple contusions and abrasions.
More severe injuries in this industry (NAICS 331525)
LOWELLVILLE, OHIO—
FALCON FOUNDRY CO.
An employee tried to catch a metal casting being laid down with chains by rigging equipment. The casting started to slip in the chains, causing the employee's left middle finger to be pinched by the chains and resulting in an amputation down to the first knuckle.
LANCASTER, PENNSYLVANIA—
J. Walter Miller Company
An employee was investigating the chain of a pallet jack that had hung up. The chain pulled tight and amputated the employee's left index fingertip.
FORT WORTH, TEXAS—
Midland Manufacturing Company
An employee fell while walking in a warehouse, injuring his left hip.
WAKEMAN, OHIO—
Concast Metal Products
On January 31, 2020, an employee was tearing down a die and emptying molten metal from a mold when the molten metal contacted the employee, burning his right leg and ankle. He was hospitalized.
LANCASTER, PENNSYLVANIA—
J. Walter Miller Company
An employee was using a powered hand truck to move scrap from a cutoff area to a foundry. The employee's left little finger was rammed into a wall and sustained an open fracture, with amputation of the fingertip.
More severe injuries in OHIO
DAYTON, OHIO—
United States Postal Service
An employee was working to deliver mail to an apartment building. She was waiting for a customer to move, to obtain clearance to the mailboxes. The door swung inward and closed on her right little finger. The top half of her finger was surgically amputated.
COLUMBUS, OHIO—
Foundation Steel, LLC
An employee fell from a step ladder while reaching for a tie-off point. He impacted the ground, and landed on his bolt bag which contained tools. The employee was hospitalized with fractured ribs, and a lacerated spleen and kidney.
LIMA, OHIO—
GXO Logistics
On October 30, 2025, an employee was working to adjust a stackable metal shipping container. As the container dropped into place, it caught the employee's hands in an area between the upper and lower cross-members. The employee suffered a laceration to the left ring finger that required stitches, bruising to the right ring finger, and fractures to the right middle finger that necessitated medical amputation of the fingertip.
CANTON, OHIO—
Abbott Electric Inc
An employee was moving a scissor lift through a doorway. The employee was pinned between the scissor lift and the doorframe, sustained a back injury, and was hospitalized.
COLUMBUS, OHIO—
American Electric Power Company
An employee was setting up communication equipment for a meeting. They were walking and tripped over a speaker on the ground. The employee sustained a leg injury.