Caught in running equipment or machinery during maintenance, cleaning · Avulsions, enucleations
At a glance
Federal OSHA recorded a severe workplace injury
at Rich Ice Cream Co., 2915 S. DIXIE HWY., WEST PALM BEACH, FLORIDA 33405
on — Avulsions, enucleations, affecting the finger(s), fingernail(s), unspecified.
Final narrative
An employee was clearing out product that had accumulated in an ice cream machine's crunch basin when his right middle finger was caught in the machine. The employee suffered an avulsion and was hospitalized.
HospitalizedFinger(s), fingernail(s), unspecifiedFood and beverage processing machinery-specialized, n.e.c.
An employee was changing pipes to run a clean-in-lace (CIP) circuit. When he loosened the clamp on the jumper at the flow panel, the pressure unexpectedly released, spraying hot water mixed with peroxyacetic acid directly in their face. The employee sustained a severe chemical burn to the face, eyes, and arms and was hospitalized.
An employee was removing a popsicle that was stuck inside the dry coating machine. The impeller blades struck his right hand and he sustained fractures and lacerations to four fingers, crushed bones in the palm of his hand, and a partial amputation of the middle finger above the last knuckle.
Two employees were repairing the hydraulic engagement pins on a rented front-end wheel loader. The machine controls were activated to move the attachment pins and an employee's finger was caught between the pins and the bushings. Their right index finger was partially amputated.
An employee was cleaning the conveyor on a piece of equipment when they slipped and their right hand was pulled into the chain sprocket. The employee's fifth fingertip was amputated.
An employee was throwing blankets onto a blanket folding and stacking machine. A blanket got stuck in the machine and she attempted to remove it when the machine contacted her right little finger, resulting in a fingertip amputation.
More severe injuries in this industry (NAICS 311520)
An employee was using an end mill to mill out a section of a metal door frame that he was fabricating. Metal shavings built up and he could not see the marking to cut, so he used a small brush to remove the shavings. While brushing off the shavings, his glove became caught in the spinning mill bit and pulled his hand in. The employee's right index finger contacted the spinning bit, resulting in a partial amputation to the side of the finger.
An employee was unjamming cookie dough from a machine when the rotating pump caught her left index and ring fingers, resulting in fingertip amputations.
An employee was marking a malfunctioning mold when their finger got caught between one section of rollers on the mold and the guarding on the next section of rollers. The employee's finger was amputated below the nailbed.
An employee was exiting the rear door of a freezer truck when he slipped/misstepped and fell to the ground. The employee sustained a broken right leg that required surgery.
An employee was helping a coworker transport a tall palm tree with a mini skid steer. The employee was severely shocked by a high-voltage electrical wire above the ground.
An employee was retrieving a Christmas tree from a shelf using a ladder. He missed a step and fell to the concrete floor. He sustained injury to his head and wrist.
An employee was operating an agricultural tractor during sugarcane harvesting. The employee sustained a lumbar sprain due to vibration or motion from the tractor.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.