Fall on same level due to tripping, unspecified · Soreness, pain, hurt-nonspecified injury
At a glance
Federal OSHA recorded a severe workplace injury
at Sodexo USA, 9801 Washingtonian Blvd, GAITHERSBURG, MARYLAND 20878
on — Soreness, pain, hurt-nonspecified injury, affecting the lumbar region.
Final narrative
An employee was entering the facility from outside, pushing a food cart down a ramp when they tripped and fell on the ramp. The employee sustained a lower back injury.
HospitalizedLumbar regionRamps, loading docks, dock plates
An employee was performing preventative maintenance on an air handling unit. As the employee was confirming that the variable frequency drive startup was sequencing correctly, the motor engaged and the employee's left ring finger was caught in the motor pulley. Their finger was partially amputated.
An employee was walking down the hall to retrieve a vacuum when they stumbled and fell to the floor. The employee suffered wrist bruises and a kneecap fracture that required surgery.
An employee was installing a compressor piston. He tripped and fell backward while the piston was in his lap. As he landed, the little finger of his left hand became caught between the piston and compressor piping resulting in a partial amputation of the fingertip. The employee required stitches and the fingertip was reattached.
An employee was doing an oil change. He was walking to get his oil jug when he tripped on an open lift pad, and fell to the ground landing on his right side. The employee sustained a broken right femur and was hospitalized.
More severe injuries in this industry (NAICS 722310)
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.
An employee was cleaning a steam kettle; he had the floor grate lifted to access the drain area. He tripped on the open floor grate, striking his knee against the steam kettle's drain pipe and falling onto multiple pieces of kitchen equipment. He landed on the floor, where he struck his head. He was hospitalized with lacerations to his ear, which required surgery to repair.
An employee was outside a freight elevator, reaching in, when the elevator moved and crushed her right hand. She suffered a broken arm and wrist and was hospitalized, requiring muscle surgery.
On September 29, 2025, an employee was removing a pan of pasta from the stove when the pan tipped over. Hot water contacted her legs and feet, resulting in burns to both feet that required hospitalization.
An employee was walking through a passageway sideways when the edge of her shoe got caught and she fell onto her right hip, resulting in a broken femoral head.
An employee was ascending a flight of stairs after exiting their vehicle in an adjacent employee parking lot. The employee stepped to the right to avoid another employee on the left who was descending the stairs. The employee lost their balance and fell on the stairs. They were hospitalized with a laceration/abrasion to their chin, a fractured left humerus, and bruising to their left knee.
A mail handler was moving BMCs on the loading dock when they fell from the loading dock to the concrete ground below. The employee was hospitalized with head trauma.
An employee was on an A-frame ladder while preforming demolition of a ceiling. A section of HVAC ductwork fell on the employee and knocked them to the ground approximately 12 feet below. The employee was hospitalized with a concussion and lacerations.
On the morning of July 24, 2025, an employee was conducting synthesis of a highly toxic experimental chemical (nerve agent) in a chemical fume hood. The operation was completed at approximately 11:30 AM. The employee was exposed to the chemical and began experiencing symptoms of illness/poisoning around 1:30 PM and was hospitalized.