Tetra Technologies Inc

On July 22, 2023, an employee was swinging a 5-ton hammer on a hammer union. The employee then noticed a piece of metal was lodged in his upper left thigh and required hospitalization.

An employee used a wire brush to clean the threads of two 10-foot joints of 2-inch figure 1502 iron pipe, which were sitting on the rack of a monorail trailer. As the employee rotated the pipe inward to clean the threads of the innermost joint, the opposite end of the pipe dislodged from the rack and fell to the ground. As it fell, the end nearest to the employee levered upward and pinched their right thumb between the two joints of pipe. The employee sustained a laceration and fracture to the thumb.

An employee's socks became wet while pressing on sand bags, which caused extreme blistering and skin around the area to turn black, resulting in a right toe amputation.

Two employees were transferring rinsate from a chemical tote to frac tanks using a bucket. Approximately six hours later, both employees stated that they felt winded with slightly strained breathing. One of the employees was hospitalized due to strained breathing and low oxygen levels.

An employee was holding a 55-gallon drum in place with his right leg while another employee was attempting to puncture the drum with the forks of a forklift. As the forklift operator applied pressure to the drum with the forks, the injured employee's foot became pinned to the ground under the drum, resulting in a fracture to his right leg. He was hospitalized and had surgery.

An employee was emptying and cleaning a trash container when he noticed a bite on his ribcage. The employee was hospitalized for a poisonous spider bite.

An employee was bitten by a copperhead snake while loading firewood.

An employee was working an investigation. He pulled a trash can from a suspect s house and was bitten by fire ants. On the way back to the office the employee developed hives and went into anaphylactic shock. The employee was hospitalized.

An employee was stung multiple times by bees while they were in a field. He suffered a severe allergic reaction and was hospitalized.

An employee was picking up brush and debris for storm restorations when their left index finger was bitten by a copperhead snake.

An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.

An employee was assisting the crew with patching and restoring a roadway after the installation of a sewer line. He was helping place and level the blacktop/backfill material over the trench area to bring the road surface back to proper grade. The employee was walking between a forward-moving dump truck and a dirt pile when his right foot was run over by the truck s wheel, causing him to fall. The employee sustained injury to his foot.

An employee was rigging I-beams. An I-beam slid off the stack of I-beams and fractured the employee's leg.

An employee was operating a skid steer with a bucket attachment at a demolition site. While driving it to the rear of the property to park it, the employee came into contact with a live electrical transformer unit that was located outside of the facility. The employee sustained electrical burns on his hands extending up to his elbows and a fractured ankle.

An employee was installing a door on a semi-trailer. They were using a forklift to lift the door to the height of the trailer when the door became jammed between the forklift mast and the hinge on the trailer. When the employee went to dislodge the door from the mast, the door fell and crushed their foot. Their big toe was amputated. The employee was hospitalized and their big toe was surgically reattached. The employee's foot and other toes also required surgery.

After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.

An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.

An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.

An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.

An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.