Kugler Oil Company

An employee was repairing an underground gas main when natural gas ignited and an explosion and fire occurred. The employee sustained burns.

An employee was lighting the pilot light on a water heater. Gas ignited, causing a flash fire and explosion at the residential property. The employee suffered burns to the head, neck, upper torso, and upper extremities.

An employee was preparing a reach in cooler (fry cooler) and charging the system with refrigerant (R290)with his gauges. When the employee removed the gauges from the liquid line service valve, the refrigerant immediately escaped, and the liquid refrigerant exploded due to an unknown ignition source. The employee was burned on the face, hands, abdomen and knees.

An employee was lighting a gas stove/pizza oven when an explosion occurred due to a natural gas buildup. The employee sustained first- and second-degree burns to the face, neck, arms, hands, and legs.

Employees were installing new kitchen equipment when a gas explosion occurred. One employee sustained burns to the right hand, left hand, and stomach. The other employee also sustained burns.

A shipping/receiving operator was working on a loading rack, loading a railcar. A 2-inch discharge cap failed and released pressure along with sulfuric acid from the railcar. The acid sprayed onto the employee, who suffered burns to the chest and the lower facial area. The employee was hospitalized.

An employee was on the ground unloading fertilizer when he tripped and fell over a cinder block that was on the ground. The employee was hospitalized with a fractured left hip.

An employee was performing maintenance on a pump. They replaced the pump and activated the pump motor for testing. The 7.5 HP mix tank pump impeller caught the employee's shoelace, causing their leg to get pulled against the pump housing. The employee sustained a compound fracture of the lower left leg.

On August 12, 2024, at approximately 3:20 AM, employee 1 opened the dome lid of a sulfur railcar that released hydrogen sulfide gas pressure that had built up inside the car during transportation. Employee 1 became overwhelmed by the gas and fell to the ground. Employee 2 went over to check on employee 1, when they were also overcome by the gas. Employee 2 was hospitalized for observation and employee 1 was hospitalized for inhalation injuries from the hydrogen sulfide gas.

An employee was shocked while working on a breaker at the motor control center, suffering an electrical burn to the left hand, left wrist, left side of the neck, and face.

An employee was stacking concrete blocks for a concrete bunker. As a block was swinging into place, the employee's left leg was pinched between two blocks, resulting in injuries to his left heel and lower leg.

An employee was climbing a ladder to inspect a vent in a restaurant dining area. The ladder slid out on the floor and the employee fell approximately 12 feet onto the ladder and the floor. He was hospitalized with a dislocated shoulder and a back injury.

An employee was rappelling down a tree. When he was most of the way down, he fell on the ground and suffered a broken pelvis.

An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.

An employee was cleaning out corn from a grain bin. The sweep auger in the bin was activated and caught his trouser leg. His leg was pulled into the auger, which injured his calf and caused leg fractures and lacerations.