Direct exposure to electricity, unspecified · Electrical burns, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Impact Fulfillment Services, 20 Cinnamon Oak Drive, HAZLETON, PENNSYLVANIA 18202
on — Electrical burns, unspecified, affecting the hand(s), unspecified.
Final narrative
An employee was ending his shift and preparing to plug in his forklift battery to charge. When he connected the charging cable, there was an arc flash. He sustained an electrical shock to his right hand and burns.
An employee was installing a 15-amp breaker in an electrical panel when a 12-gauge ground wire touched the positive busbar of the panel, resulting in an arc flash. The employee sustained a second-degree burn to their left hand.
An employee was repairing an HVAC system in the drop tile ceiling of a conference room when they were shocked, causing them to fall from the ladder. The employee sustained burns to their right middle and ring fingers.
An employee was replacing a contactor inside an electrical panel attached directly to a press. The press itself was receiving power from another main panel. After replacing the contactor, the employee flipped the switch and an arc flash occurred, burning the employee's elbow, bicep, and neck.
An employee was attempting to switch a medium-voltage primary cable and install a 200-amp fuse barrel. The employee contacted the bottom of the switch gear cradle for the fuse barrel, causing an arc blast. The electricity entered the employee s left hand and exited his big toes, resulting in electric shock and burns to the left hand, arm, shoulder, and both feet. The employee was hospitalized.
On December 6, 2023, an employee of Duke Energy was working on a single-phase 120-/240-volt parallel service re-tap when a secondary flash occurred in an underground service. The employee suffered a second-degree burn to the face and was hospitalized.
More severe injuries in this industry (NAICS 561990)
An employee was performing flagging operations on a closed road. A postal vehicle was allowed onto the road to make a delivery. The employee was struck by the postal vehicle as it was backing up, resulting in a broken leg.
An employee was walking and taking post-locate photos. He stepped on a ceramic drainage tile and his foot/leg punched through the tile. His leg was lacerated by the broken tile. The employee was hospitalized with internal bleeding due to a punctured femoral artery.
Employees were preparing to place a section of metal grating measuring approximately 50" x 18" and weighing 40 to 50 lbs. The injured employee grabbed the grating to pull it toward himself and another employee was moving to the other side to assist with the lift. As the injured employee pulled, his right foot slipped and twisted. He was hospitalized with a fractured right leg.
An employee was in their personal vehicle awaiting instructions from the construction contractor on posting traffic cones. The driver of a motor vehicle swerved to avoid a steel plate in the roadway and struck the employee's car. The employee was hospitalized with four fractured ribs.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.