McCain Foods, USA Inc.

An employee was putting a machine guard back onto a chain and sprocket when their left middle finger became caught in the chain and sprocket. The employee sustained an amputation of the fingertip.

On December 3, 2024, at approximately 11:30 PM, electronic technicians were adjusting a tensioning chain on an elevator on a palletizer that had become unlevel. After loosening the tensioners and creating slack in the chain, the injured employee was placing the tensioning chain back onto the sprocket. While moving the chain it regained tension and their left middle fingertip was caught between the chain and the sprocket and was amputated.

An employee was cleaning jammed potatoes from the top of a roll sizer in the raw receiving area when her right index finger was caught in the chain, resulting in hospitalization and a fingertip amputation.

On December 12, 2023, at approximately 3:00 a.m., an employee was unplugging a drain with a powered snake tool when his left hand was caught in the snake cable. The cable pinched his left ring finger, resulting in a fracture and partial fingertip amputation.

An employee was standing on a step stool to sort pickles on a moving wire conveyor belt. The employee's finger became stuck in a hole of the conveyor belt, striking a cross piece. The employee's right little fingertip was amputated.

An employee was stepping out of a car when they slipped and fell on ice, resulting in a femur fracture.

An employee was closing up for the weekend when they slipped on oil and brake fluid and fell. The employee suffered a leg fracture.

An employee was working in the forest flagging an area to be harvested. He took a step and his foot slipped on a stick hidden under the leaves, causing him to fall to the ground. He landed on his right foot/lower leg resulting in a fractured tibia.

An employee was inspecting an apartment to ensure it was ready for a new resident to move in. The carpet in the apartment had been recently cleaned and was still wet. As the employee went from the carpet to the tiled floor of the bathroom, they slipped and fell, resulting in a torn left hamstring.

An employee was delivering a letter along a rural carrier route when she stepped on an ice-covered snow drift, slipped, and fell to the ground. The employee sustained a right hip fracture that required surgery.

An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.

An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.

An employee was walking on top of boiler to close a valve. The employee fell off the boiler and landed on the floor, sustaining fractured ribs. The employee was hospitalized.

An employee was inspecting a pipe in the rice cooking area near an oven. While checking for a clog, the fingers of their right hand were caught in an airlock at the base of the pipe. All the fingers were amputated except the thumb. The employee was hospitalized.

An employee was removing dough from the discharge at the bottom of a mixer when the scraper contacted his left index finger and amputated it.

The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.

An employee was using a vertical band saw to cut a thick piece of rubber material. While being cut, the material shifted, causing the employee s right hand to contact the moving blade. The employee's thumb was amputated below the knuckle. The employee was hospitalized, undergoing surgery.

A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.

An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.

An employee was unloading a truck for a delivery job. While moving boxes in the truck, the employee tripped over a pallet and fell out of the truck to the ground, resulting in four broken ribs.