HT Energy LLC

Mechanics were straightening a ladder on the derrick in the shop using an acetylene torch and a 10-ton hydraulic jack. As the mechanics were extending the jack to straighten out the ladder, the cylinder on the jack was turning and the quick-connect fitting ended up against the footrail of the derrick. This caused the nipple to break and a mist of oil was released from the jack. The oil mist ignited resulting in a flash fire. The injured employee sustained second- to third-degree burns burns to the right hand, the left cheek, and the left side of their neck as well as burns to both arms. The employee was hospitalized.

A crew was running rods in the hole when the chain on the rod transfer broke and fell to the rig floor. The chain struck the injured employee on the hard hat and whipped underneath the hard hat and struck the employee above their nose, causing a fracture and laceration. The employee was hospitalized.

An employee was greasing tongs on a work-over rig. The tongs lacerated one of the employee's fingers.

An employee was in the yard area on a forklift pulling lumber. Inclement weather began and the employee stopped the forklift and was walking to a safe location when they were struck by flying debris from the high winds or tornado. The employee sustained a leg fracture.

An employee was working at a job site when something flew into his eye. He was hospitalized with a cut on his cornea.

After reassembly work on a ready-mix truck, an employee turned the truck on to check for leaks. The employee was standing on the truck platform, about 3 feet off the ground, when he heard an air leak. As he was turning off the truck, a flying bolt from the plate assembly struck his forehead and broke his skull. He was hospitalized.

An employee was using an air hammer when a piece of metal struck their eye.

An employee was working on the parking brake for a piece of equipment when the 60-pound tension plate on the parking break released, striking the employee and causing him to stumble backward and fall. The employee suffered a broken leg that required hospitalization.

An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.

An employee was delivering home heating fuel when bees came from the ground and stung the employee's face, neck, torso, and hands. The employee proceeded to shut off the oil flow before losing consciousness. They were hospitalized due to an anaphylactic reaction.

An employee was using a torch to loosen a bolt on a water trailer. Natural gas was present in the water and it ignited, causing a fire. The employee sustained third-degree burns to their upper leg.

An employee had been conducting crane operations. The employee went to stop a piece of oil and gas equipment for tubular running from falling over to the ground. Their right hand was caught between a rolling ladder and the equipment, resulting in fractures to the index and middle fingers. They were hospitalized and the middle finger required surgery.

An employee was working to install a drive belt on a water pump. He was holding the belt on both sides of the pulley, working to route it over the top. As he pulled down with his right hand, the pulley rotated and the belt slid over it, pulling his left little finger between the pulley and the belt. He suffered an amputation to the fingertip as well as a fracture to the ring finger.

After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.

An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.

An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.

An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.

An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.