Federal OSHA recorded a severe workplace injury
at PF Automotive LLC, 2200 West University Drive, PROSPER, TEXAS 75078
on — Amputations, avulsions, enucleations unspecified, affecting the Finger or thumb tip(s), nail(s).
Final narrative
An employee was replacing bushings on a vehicle. The tool the employee was using broke causing the car frame to lower and crush the employee's finger, resulting in a fingertip amputation.
Amputation Finger or thumb tip(s), nail(s) Automobile
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
An employee was installing a hydraulic extension cylinder in a tow truck when their leg was caught between the cylinder and the truck frame. The employee was hospitalized with a broken tibia, which required surgery.
An employee was sorting sucker rods. His right hand was caught in the area where the rod hits up against the frame and his index fingertip was amputated just below the nail.
More severe injuries in this industry (NAICS 441110)
An employee was working underneath a vehicle when the vehicle began to roll and a tire caught the employee's left ear. The employee sustained a laceration and partial amputation of their ear, requiring hospitalization and surgery to reattach the ear.
A car was being backed out of a bay so that another car could pull into it. The car's brakes did not respond, and the car reversed quickly. The injured employee approached the car to stop it, and it pinned his right leg against a lift. The employee was hospitalized.
An employee was exiting the company shuttle van when his shoe became caught on the door of the vehicle, causing him to fall out of the van to the ground. The employee was hospitalized with a fractured hip that required surgery.
An employee was working to change the tires and brakes on a vehicle. He pulled the vehicle out of the bay. The brakes failed, and the car drifted backward into another bay where it pinned the injured employee against the arm of a vehicle lift. The injured employee sustained seven fractured ribs on his left side.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.