Contact incidents unspecified · Traumatic injuries or exposures unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Wellborn Cabinet, Inc., 3869 Highway 77, ASHLAND, ALABAMA 36251
on — Traumatic injuries or exposures unspecified, affecting the Part of body unspecified.
Final narrative
An employee was assisting with rolling a tarp when the spring-loaded arm that assists with rolling the tarp became bound. When it came free from a shaft, it struck the employee and they lost consciousness.
Hospitalized Part of body unspecified Source, secondary source unspecified
An employee was planing a 12"x37"x3/4" piece of maple when the tip of her glove was caught by carbon rollers on the planer, pulling her left middle finger into the planer. The employee suffered a partial finger amputation between the middle and proximal joints.
An employee was operating the trim saw machine when his gloved left middle finger got caught between the sprockets and chain resulting in amputation of the finger.
An employee was attempting to blow dust from a machine. The air hose got stuck in the machine and as the employee went to retrieve the hose from the machine the saw blade partially amputated their right middle finger. The entire finger was medically amputated.
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
An employee was installing a hydraulic extension cylinder in a tow truck when their leg was caught between the cylinder and the truck frame. The employee was hospitalized with a broken tibia, which required surgery.
An employee was sorting sucker rods. His right hand was caught in the area where the rod hits up against the frame and his index fingertip was amputated just below the nail.
More severe injuries in this industry (NAICS 337110)
An employee fell to an office floor, landing on her right side and suffering a broken hip, a broken right arm, and a concussion. She was hospitalized, requiring surgery.
An employee was clearing a small piece of wood that had jammed in the back of a machine. A cutting blade in the machine lacerated the employee's right forearm. The employee was hospitalized, requiring surgery.
An employee was operating a stand-up forklift to travel from the warehouse to the breakroom area. The forklift struck the breakroom wall, causing a fracture/crush injury to his left foot.
An employee was cutting a piece of wood with a table saw. The wood bound in the saw, which then pulled the employee's right hand into the blade. His middle finger was cut and fractured.
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.