Struck by dislodged or detached object(s) · Closed trauma involving internal organs, major blood vessels
At a glance
Federal OSHA recorded a severe workplace injury
at Viterra USA Grain, LLC, 1601 Terminal Road, MACEO, KENTUCKY 42355
on — Closed trauma involving internal organs, major blood vessels , affecting the Multiple internal abdominal locations.
Final narrative
An employee was using a winch to secure a barge to a dock. The cable of an adjoining winch snapped and struck his left side, causing blunt force trauma and internal injuries to his abdomen.
An employee was using a metal rod that was approximately 1-2 feet long to poke upward toward the product and unplug a bin that was plugged. The gate under the bin is controlled by the neighboring facility, which closed the gate while the rod was still inside it. The rod was pushed against the employee's finger, trapping it against an adjacent wall and resulting in a partial amputation through the phalanx.
An employee was operating an ironworker (steel punching/shearing) machine. A piece of the tooling broke off and struck the employee's neck; a fragment was lodged in his neck. The employee was hospitalized and required surgery.
A service crew was pulling a pump and motor from a well. After breaking a joint of pipe loose from another joint, an employee grabbed the chain tongs to prevent the pipe from spinning in the well, so the crew could continue taking it apart. The bolt that attaches the chain to the handle of the chain tongs broke, causing the chain to swing around and strike the employee's lower right leg. The chain severely punctured his leg and fractured his tibia.
An employee was using a handheld grinder to cut a bolt. The grinding wheel broke apart and a fragment struck the employee s right hand, causing a laceration to the palm near the little finger.
An employee was operating a brake press when the top die broke, causing the bottom die to roll out and onto the employee's legs. Both of the employee's legs were crushed below the knee, and both legs were partially amputated. The employee's left leg was also fractured above the knee.
A pressurized aircraft nose landing gear strut assembly was being disassembled. The gland nut dislodged under pressure and made contact with an employee's left hand, breaking it.
More severe injuries in this industry (NAICS 424510)
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
An employee was walking past a crossover conveyor when a ramp came down and hit them in the back. The employee sustained a broken back vertebra, as well as a concussion, and was hospitalized.
An employee bent over to pick up a rubber mat from the ground. When he grabbed the corner of the mat, a rattlesnake hidden under it bit his left middle finger near the first knuckle. He was hospitalized.
An employee had been cleaning a grain bin. He walked across the bin and his left foot contacted an unguarded floor auger, resulting in severe lacerations to the foot. The auger was not locked out/tagged out at the time.
On September 23, 2025, an employee was monitoring a feed roller when they tripped and their right hand contacted the roller. The employee was hospitalized and their right hand was amputated at the wrist.
A mail carrier was delivering mail when aggressive dogs approached. The dog's owner tried to restrain the dogs but one dog broke loose and the mail carrier pepper sprayed that dog. The dog's owner then pushed the mail carrier and he fell on the pavement and injured his neck. The mail carrier was hospitalized.
An employee was installing a fall protection system on a flat roof when they tripped and became entangled in the warning line. They fell approximately 30 feet to the ground below. The employee sustained fractures.
An employee was outside assembling a 500-ton crane. The employee was connecting the rigging to the boom. He leaned forward to attach the lifting plate on the side of the boom and lost balance while bending over. He fell to the ground approximately 10 feet below, landing on his elbow. The employee was hospitalized with a fractured elbow that required surgery.
A mail carrier stepped out of his vehicle and into a large hole in the ground that was covered by the unkept yard. The hole had a piece of clay pipe exposed. The employee was hospitalized with a lacerated right Achilles tendon and required surgery.