Pedestrian struck by forward-moving vehicle in nonroadway area · Amputations involving bone loss
At a glance
Federal OSHA recorded a severe workplace injury
at Chobani, LLC, 669 County Road 25, NEW BERLIN, NEW YORK 13411
on — Amputations involving bone loss, affecting the Other finger(s) n.e.c..
Final narrative
An employee was training other employees on inspecting finished goods on a pallet. When he knelt down behind the pallet and used his left hand to indicate what the failed inspection point was, a riding pallet jack entered the staging area and the employee's left little finger was crushed between the end of the fork and the pallet. The distal phalanx was medically amputated.
Amputation Other finger(s) n.e.c. Pallet jack riding
An employee was clearing a cup jam on a cup conveyor when their left hand was caught between the conveyor and an idler roller located on another conveyor line directly above the jam. The employee received an abrasion and friction burn to the hand that required hospitalization.
An employee was assisting in the repositioning of an industrial freezer when their right ring fingertip became pinched between two freezers. The fingertip was amputated.
An employee was clearing a cup/foil jam on a filler when they were injured by the yogurt cup conveyor. The employee sustained lacerations to the left arm and left side and fractures to the left arm.
An employee was checking credentials for vehicles entering an area. While approaching a vehicle that had failed to stop as instructed, the employee lost his balance and fell backward, landing on his back. The car struck him, and he suffered a tailbone fracture and a kidney injury.
An employee was riding on the side of a forklift. He stepped off the forklift and was struck by the back end of the forklift as it turned to the right. The forklift's back tire ran over his leg, resulting in an amputation. The employee was hospitalized.
An employee was closing a rear trailer door in the parking lot when they were struck by a forklift. The employee's lower left leg was crushed between the pallet on the forklift and the trailer. The employee sustained muscle damage to their lower leg.
An employee was guiding a customer's automobile onto the alignment rack when the vehicle drove over the rack and pinned the employee against the alignment computer. The employee sustained a bruised left hand and a fractured left fibula and was hospitalized.
A backhoe tractor was moving gravel into a 1-foot-deep trench, and an employee was helping spread the gravel. The trench had been partly filled and the tractor was returning to it with a load of stone when its raised bucket struck the employee, who was standing in the trench. He was hospitalized, having suffered an abdominal injury that caused internal bleeding.
More severe injuries in this industry (NAICS 311511)
An employee was performing rear brake shoe service on a truck. The employee was using a prybar to remove a spring when the spring slipped from the S-cam and amputated his left index fingertip.
An employee was unjamming a case that was stuck in a case washer machine when their pants became entangled in a chain, causing them to be sprayed with hot water from the machine. They employee suffered burns from the hot water.
An employee was clearing a cup jam on a cup conveyor when their left hand was caught between the conveyor and an idler roller located on another conveyor line directly above the jam. The employee received an abrasion and friction burn to the hand that required hospitalization.
An employee was performing routine maintenance on an air valve when their right ring finger became caught in the valve. The employee sustained an amputation to the fingertip.
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
An employee slipped while descending in a stairwell, fell, and suffered multiple contusions/bruises to the head, neck, shoulders, knees, and back. She was hospitalized.
An employee was directing trucks as they entered and left a highway work zone. A vehicle struck them, resulting in multiple fractures and other injuries. The employee was hospitalized.