Struck by other falling object n.e.c. · Other traumatic injuries n.e.c.
At a glance
Federal OSHA recorded a severe workplace injury
at General Dynamics Nassco Norfolk, 200 Ligon Street, NORFOLK, VIRGINIA 23523
on — Other traumatic injuries n.e.c., affecting the Lower leg(s).
Final narrative
At about 8:30 a.m. on February 11, 2025, four employees were removing a 5-foot-long waster sleeve from under a vessel. A raised platform was being used to allow a pneumatic jack to press out the waster sleeve. The employees stacked four wooden blocks, about 12 inches by 12 inches by 51 inches, and placed a 3/8-inch blank plate on the blocks. They then placed the pneumatic jack on the top of the blank to press up the waster sleeve from the underside of the vessel. The jack was put into action, but the waster sleeve did not move. The block structure became unstable, collapsed, and struck an employee in the lower left shin area. The employee developed swelling in the lower leg that resulted in hospitalization for compartment syndrome that required surgery.
Employees were on the port side catwalk of an amphibious assault ship, pinning a chaff launcher to a foundation unit. As the injured employee was aligning the launcher, his left index fingertip was amputated in the bolt/pin hole.
At 9:30 a.m. on March 7, 2022, an employee was operating a drill press when the drill paddle bit became hung up in the block. The employee began backing out the bit, and was trying to pry it free, when the shaft of the bit bent. When it came out of the block, it came around and struck the employee in the left elbow, then the upper left side of his ribs. He suffered a collapsed lung, as well as a laceration, and was hospitalized.
On July 2, 2015, at 1425 hours, an employee was cutting inside a water tank on the U.S.S. Bataan at BAE Shipyard in the TITAN Dry-dock when he received an electrical shock from a welding lead. He was hospitalized.
An employee working onboard the U.S.S. Eisenhower at Portsmouth Naval Shipyard contacted a piece of energized wire that was encased in a steel pipe conduit.
The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.
An employee was helping to move a 1,300-pound coil on a cart. The steel caster hit a crack in the concrete, the weld holding the caster onto the cart broke, and the coil and cart tipped over onto the employee. He was hospitalized with a laceration on his forehead and a pelvic fracture on his right side.
An employee was attempting to lift a steel beam from a horizontal, stacked position to a vertical position using a crane. They had placed two hooks on the east side of the beam on the flange. As the employee was hoisting the crane, the beam began to shift and pulled the employee forward onto the stack. When the material shifted, the hooks released and the material fell, pinning the employee between the two beams. The employee was hospitalized with soft tissue contusions on their proximal right thigh and interior left thigh.
An employee was moving a tensile strength test device with a dolly. The device fell from the dolly onto the employee's right leg, causing a compound fracture.
An employee was hooking up bundled tie-downs with a chain. While he was holding a hook, the other hook was unlocked. This caused the employee's hook to slide down and pinch his right index finger between the chain and the shackle. He suffered an amputation to the fingertip (without bone loss), as well as an open fracture.
An employee was preparing to bend a flat bar in a brake press. When the machine was jogged, the stock rotated up and crushed his left middle fingertip against the outer frame of the die. The fingertip was amputated.
An employee was cutting metal with a torch. A piece of metal struck the employee's left foot, causing multiple fractures to metatarsal(s). The employee was hospitalized.
An employee was descending a ladder carrying a bag of trash. He fell, landed on the ground about 10 feet below, and suffered fractures to his right hip and pelvis.
A building engineer was inspecting a generator. As he closed the generator enclosure door, his right ring finger was caught between the door and the door frame. The fingertip was amputated.
An employee was walking back to a carrier case with mail in her hand when she tripped over a tub. Her back overarched as she fell, resulting in a fractured back that required hospitalization.
An employee was driving a utility tractor rig when it struck the rear trailer of another utility tractor rig, which was traveling in the opposite direction. The glancing impact caused damage to the cab, and he sustained a laceration on right side of his face, a cervical fracture, two fractured left ribs, and a pelvic fracture. The employee was hospitalized.
An employee was washing an aircraft from a scissor lift when they fell to the floor. The employee sustained a back injury and lacerations to their head and neck.