An employee had been using an air gun to blow cotton off the moving parts inside of the length/strength cabinet. The employee went to grab some cotton that was still stuck on the length/strength breaker bracket (above the rear jaw cylinder) when their left fourth finger became pinched. The employee sustained an amputation through the distal phalanx.
Amputation Other finger(s) n.e.c. Picking, carding, combing machinery
A temporary employee turned off a planer machine, opened the housing, and began clearing a jam. The machine's spinning blade caught his right hand and degloved the index finger.
An employee was using a tool to remove a rag from a roll on the tube mill. The roll pulled the tool and the employee's right hand into the roll, resulting in a partial amputation of the little finger and a fracture to the index finger.
A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.
More severe injuries in this industry (NAICS 115114)
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
On May 3, 2025, at approximately 8:45 AM, an employee was cleaning the surface of a sonic bag sealer with an emery cloth when the sealer activated and closed on their fingers. The employee sustained burns to three fingers on their right hand. The machine was not locked out at the time.
An employee was riding a manlift (elevator) up to the fourth floor of a building. His right leg was struck and pinched by the third-floor structure as he ascended. The leg was broken.
An employee was operating a forklift in a warehouse with closed bay doors. The forklift was in operation for about 90 minutes in the enclosed area. Two employees working in the area developed carbon monoxide poisoning and were hospitalized.
The injured employee was assisting a Department of Homeland Security (DHS) enforcement operation. During an apprehension, officers returned fire at a subject and struck the employee with a bullet. The employee sustained a gunshot wound to their right hand.
The injured employee was assisting in the disassembly phase after a radar array had been lowered and secured. The crew began removing load bearing pins from an overhead crane to free the radome. A load bearing pin was stuck. The injured employee went to remove the pin manually as a second team member applied pressure from the opposite side. The pin unexpectedly released and struck the injured employee s right thumb, resulting in partial amputation of the distal phalanx including an open distal phalanx fracture and nail bed laceration.
At about 3:10 p.m. on October 3, 2025, an employee was inspecting a car. Two dogs that had been in another car were leashed and tethered to a bollard. As the employee inspected the first car along with a narcotics detection dog, one of the other dogs came loose and attacked the narcotics dog. The employee was separating the dogs when the other dog bit his left ring finger. The last joint of the finger was injured and part of it was bitten off.
An employee was preparing a bundle of green onions for chopping. While holding the bundle in his left hand, he made his first cut using a 9-inch kitchen knife held in his right hand. The knife contacted the tip of his left thumb, resulting in an amputation of approximately 0.5 inches of the thumb that required hospitalization.