Entangled in non-running object · Amputations involving bone loss
At a glance
Federal OSHA recorded a severe workplace injury
at TK Elevator Corporation, 3600 Lacey Road Ste 100, DOWNERS GROVE, ILLINOIS 60515
on — Amputations involving bone loss, affecting the Finger or thumb tip(s), nail(s).
Final narrative
An employee was in an elevator pit working on the hoisting cables and compensator sheave. He moved the cables back onto the sheave groves. One of the cables spun, twisted out of the grove, grabbed his glove, and pulled his hand into the sheave. The tip of his right thumb was caught under a cable and was amputated approximately at the knuckle just below the nail.
Amputation Finger or thumb tip(s), nail(s) Wire, cables nonelectrified
On January 30, 2024, a maintenance employee was cleaning and wiping down the inside of an elevator with their left hand when their cleaning cloth got snagged on moving equipment, causing their hand to become caught in the equipment as well. The employee fractured her left middle finger and sustained a cut requiring stitches and was hospitalized.
Multiple employees were working to treat a bloated animal in a cattle pen. They put a head restraint on the animal. A chain attached to the head restraint device caught the injured employee's index finger, resulting in a fingertip amputation around the fingernail area that required surgical amputation at the first knuckle.
Three employees were pulling tension cable (similar to rebar) through the walls of a condo using a motor system. Two employees were needed to hold the cable while the third employee drilled the mounting locations. When the third employee activated the drill, the cables twisted. They caught the right index finger of one of the other two employees, amputating his fingertip.
An employee was lowering an above-head gate with chains while moving a cow into a lane. Their fingers got tangled in the chain as the gate dropped, resulting in a lacerated thumb and crushed index and middle fingers.
A crew was removing old distribution poles. As they were removing the bottom section of a pole post, a winch line became tangled with slack. Two of the employees climbed on top of the crew's truck to fix the issue. The load then pulled the winch line tight around the finger of one of the employees, causing the amputation of their fingertip.
More severe injuries in this industry (NAICS 811490)
A building engineer was inspecting a generator. As he closed the generator enclosure door, his right ring finger was caught between the door and the door frame. The fingertip was amputated.
An employee was planing lumber on a jointer. While he was feeding the workpiece into the jointer, it hung up and he lost his grip on it. His gloved hand came into contact with the point of operation, and his left little finger was partially amputated near the first joint.
An employee was on an extension ladder cleaning an outdoor dryer duct when he fell to the concrete ground. The employee sustained two brain bleeds, punctured lungs, fractures to their hip, tibia, face, vertebrae, left wrist, shoulder, and upper arm, as well as an open fracture to the arm.
An employee had used cleaning solvent to clean the engine room. The employee turned on a vacuum, which caused an explosion to occur, followed by a fire. The employee was hospitalized with second-degree burns.
An employee was on a six-foot ladder to inspect the mounting bracket for a rollup door. As the employee was adjusting the position of the bracket, the ladder pushed out from under the employee and the employee fell to the ground, breaking their left arm and dislocating their right shoulder.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.