Other fall to lower level 6 to 30 feet · Closed trauma involving internal organs, major blood vessels
At a glance
Federal OSHA recorded a severe workplace injury
at SIKA CORPORATION, 888 Dunbarton Rd, MANCHESTER, NEW HAMPSHIRE 03102
on — Closed trauma involving internal organs, major blood vessels , affecting the Multiple internal chest locations.
Final narrative
An employee fell from the top of a fixed ladder, passing through the ladder's access opening and landing on the floor about 6-7 feet below. He suffered nine broken ribs (four on the left side and five on the right), as well as a punctured lung. He was hospitalized.
Hospitalized Multiple internal chest locations Fixed ladder or fire escape
On April 8, 2025, an employee was unjamming a conveyor belt. It reactivated, and his right little finger was caught between the belt and a conveyor roller. He suffered a partial amputation of the fingertip.
An employee was moving a 30-to 40-gallon container of cement/mortar that was on wheels. The container tipped over onto the employee resulting in a back fracture.
An employee was receiving trimmed PVC membrane pieces from a calendar when his finger came in contact with the blade amputating a fingertip. He was wearing cut-resistant gloves at the time of the incident.
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
An employee was standing on the surface of a steel beam about two feet wide. He slipped and fell backward, landing on the concrete ground about 20 feet below. The employee sustained a broken pelvis.
An employee was cleaning out an inlet pipe in a stormwater structure. The employee stepped back, fell into the pipe, and landed on concrete 13 feet below, at the bottom of the structure. He suffered a broken back.
An employee was working on a platform, raised 6 to 8 feet in the air, to get something off a rack. The employee fell from the platform to the ground and sustained a head injury and injury to multiple body parts.
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
More severe injuries in this industry (NAICS 325520)
An employee was rolling up sheets of sealant using a rotating mandrel when her right hand was caught in the mandrel. Her right arm was pulled into the roll of material. The employee was hospitalized with three fractures to her right arm.
An employee worked a full shift and later started cramping up due to exposure to heat and high humidity. The employee was hospitalized with heat exhaustion.
At 2:05 p.m., the injured employee was shadowing another operator. They went into the aerosol gashouse as part of training. As they entered, the self-closing overhead door shut while the injured employee's right hand was still on the edge. The employee's little fingertip was caught and partially amputated between the door and the frame.
On April 8, 2025, an employee was unjamming a conveyor belt. It reactivated, and his right little finger was caught between the belt and a conveyor roller. He suffered a partial amputation of the fingertip.
An employee was troubleshooting an alarm on an aerosol paint can filling machine when his hand was caught in a pinch point. The employee's finger was partially amputated and required surgery.
An employee was lowering the bucket of a track loader that contained a grade stake and the grade stake punctured his foot, resulting in hospitalization and surgery.
An employee was using a pike to move a pallet of sugar that was stuck in the powder racking. The employee fell backward, landing on his right leg. The employee's leg was fractured and he was hospitalized.
An employee was working to fix the forks on a forklift when the fork(s) fell on her toes. The second and third toes on her right foot were fractured, lacerated, and required stitches.
An employee was delivering a 65-foot boom lift to a rental customer's construction site. The employee set up the ramp truck in the parking lot adjacent to the construction site. He elevated the boom 4-5 feet to clear a temporary fence. While driving the boom lift off the ramp, the wheels slid to the driver's side of the ramp truck, ultimately sliding off the ramp. The boom lift fell off the side of the truck and rolled onto its side. The employee sustained a fractured clavicle, a dislocated shoulder, separated/fractured ribs, a punctured lung, and a fractured left femur. The employee required surgery.