CHASE, KANSAS—
Cal-Maine Foods Inc
Other fall to lower level 6 to 30 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at Cal-Maine Foods Inc, 1185 6th Rd, CHASE, KANSAS 67524 on — Fractures , affecting the Lower leg(s).
Final narrative
An employee was doing housekeeping work inside a chicken house. The employee missed a step onto a walkway near the exit, fell into an 8-foot-deep pit, and landed on its concrete floor. The employee suffered a leg fracture above the ankle, as well as a chin laceration.
More severe injuries at Cal-Maine Foods Inc
BOLING, TEXAS—
Cal-Maine Foods, Inc.
An employee was hospitalized after he was found lying on a warehouse floor, bleeding from his nose and right ear. The employee sustained a depressed skull fracture on the right side of his head, multiple dislocated cervical fractures, a laceration to his right ear, a fracture to his right scapula tip, and wedge compression fractures to his T2 and T4 vertebrae.
HOBOKEN, GEORGIA—
Cal-Maine Foods, Inc.
An employee was troubleshooting a conveyor belt when their fingers became caught in a drive chain. The employee sustained an amputation of the right index fingertip.
MARION, TEXAS—
Cal-Maine Foods Inc.
A maintenance employee was repairing a torn belt on a belt conveyor and contacted an energized wire. The employee sustained burn injuries from electric shock and was hospitalized.
LAKE CITY, FLORIDA—
Cal Maine Foods, Inc.
An employee was repairing a water pump on a lawn mower. He replaced the water pump and thermometer and then went to test drive it. The mower started running hot, so he brought it back to the shop and opened the hood on the mower. The radiator overflowed the bottle, the lid blew off, and hot coolant sprayed the employee's face, eyes, and neck. The employee was hospitalized for burns.
GREEN FOREST, ARKANSAS—
Cal-Maine Foods, Inc.
An employee was standing on a trough to reach tools above a fan. As they descended the trough, their hand contacted the fan and their left ring finger was amputated.
View Cal-Maine Foods Inc's full OSHA safety record →
Similar incidents · Same event type
SYRACUSE, NEW YORK—
Cashless Tolling Constructors
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
JAMAICA, NEW YORK—
Cornell & Company, Inc.
An employee was standing on the surface of a steel beam about two feet wide. He slipped and fell backward, landing on the concrete ground about 20 feet below. The employee sustained a broken pelvis.
CRESTVIEW, FLORIDA—
Anderson Columbia Co., Inc.
An employee was cleaning out an inlet pipe in a stormwater structure. The employee stepped back, fell into the pipe, and landed on concrete 13 feet below, at the bottom of the structure. He suffered a broken back.
ATLANTA, GEORGIA—
Freeman Expositions, LLC
An employee was working on a platform, raised 6 to 8 feet in the air, to get something off a rack. The employee fell from the platform to the ground and sustained a head injury and injury to multiple body parts.
CANAL WINCHESTER, OHIO—
Faler Feed Store, Inc.
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
More severe injuries in this industry (NAICS 112310)
WAKEFIELD, NEBRASKA—
M.G. Waldbaum
Three employees were transferring a metal lid using a manual chain hoist to place it onto a cart. While they were adjusting its position, the lid shifted and the injured employee's left hand became caught between the hoist hook and the handle, resulting in a laceration and amputation of their ring fingertip including the tuft.
WAKEFIELD, NEBRASKA—
Michael Foods, Inc.
An employee was using an 8-foot metal pipe to remove a manure blockage at the transfer to an incline conveyer. The employee s left hand was placed on top of the pipe while removing the blockage. The pipe pushed their left hand into the wooden railing of the platform they were standing on, catching their thumb in a pinch point and resulting in partial amputation.
CHAZY, NEW YORK—
Giroux's Poultry Farm Inc.
An employee was driving a farm truck with the dump box raised when he went through a farm building accessway and the dump box struck the entryway of the building. The truck lifted up and came back down, jolting the employee. The employee sustained a back injury.
MERCERSBURG, PENNSYLVANIA—
Herbruck's of PA, LLC
An employee was troubleshooting a manure belt to figure out why it kept turning off. The employee's right hand was pulled into the drive and compression roller of the long belt in the manure belt system, resulting in numerous injuries to their hand and forearm, including a partial amputation of the middle finger and a degloved palm.
BOLING, TEXAS—
Cal-Maine Foods, Inc.
An employee was hospitalized after he was found lying on a warehouse floor, bleeding from his nose and right ear. The employee sustained a depressed skull fracture on the right side of his head, multiple dislocated cervical fractures, a laceration to his right ear, a fracture to his right scapula tip, and wedge compression fractures to his T2 and T4 vertebrae.
More severe injuries in KANSAS
WATHENA, KANSAS—
Omya Inc.
An employee was working to remove a product blockage from a piece of equipment. The employee was struck by a metal bar near the deck of the pin mixer equipment and sustained blunt force trauma to the torso.
COFFEYVILLE, KANSAS—
John Deere Coffeyville Works
An employee was moving a rack onto a lower conveyor in the south heat treat area when their finger got caught between the part tray and the rollers, resulting in a fingertip fracture and amputation.
HAVEN, KANSAS—
Haven Steel Products Inc
An employee was climbing a ladder to get on top of the breakroom. The ladder slipped, causing him to fall to the ground. The employee sustained fractures to his upper back, left foot, and ankle.
MINNEOLA, KANSAS—
Vestas-American Wind Tech
Two employees were removing a circuit breaker. The injured employee was using wrenches in the removal process. One of the wrenches contacted an adjacent door, resulting in an arc flash. The employee suffered burns to their neck, face, and ear, as well as momentary vision loss due to the flash.
MEADE, KANSAS—
Alliance Ag and Grain LLC
An employee bent over to pick up a rubber mat from the ground. When he grabbed the corner of the mat, a rattlesnake hidden under it bit his left middle finger near the first knuckle. He was hospitalized.