Fall to lower level caught self or curtailed · Cuts, lacerations, punctures without injury to internal structures
At a glance
Federal OSHA recorded a severe workplace injury
at Fluor, 45 FM 2987, FANNIN, TEXAS 77960
on — Cuts, lacerations, punctures without injury to internal structures, affecting the Upper arm(s).
Final narrative
An employee was performing preventive maintenance activities that included cleaning coils on a turbine oil cooler. The employee used a 6-foot step ladder to access the mid-flange area, where he stood to access the oil cooler, apply silicon in-between the flanges, and bolt up the flanges. As he was standing on the side of the cooler, he fell from a height of less than 4 feet but managed to catch himself during the fall. In doing so, his left triceps contacted the threads of an existing stud that secured the top cover, resulting in a puncture wound that required hospitalization.
An employee was working to free a load by grabbing and shaking the live side of a tugger line. Once the load became free and progressed upward, the employee's hand was caught and pulled into a snatch block. The employee's right thumb was broken and lacerated. The employee was hospitalized and required a surgical amputation.
An employee lost his footing while climbing an inclined ladder. He stumbled down one step and was able to stabilize himself by holding the railing and twisting his body, but he suffered an internal abdominal injury and was hospitalized.
An employee was climbing a ladder to inspect the roof of a church when the ladder slipped and the employee fell. He went to grab the rain gutter along the eave to break his fall when his right hand contacted a sharp edge on the gutter, resulting in a laceration to the right-hand fingers that required hospitalization.
An employee was preparing a commercial jet-liner to be repainted. He had accessed the wing via a scissor lift, and was standing on a flap over an aft wing box, at a height of approximately 15 feet. His harness was on, and he was hooked up to the scissor lift yoyo. He slipped off the top of the wing and fell approximately 6 feet, making contact with the plane and scissor lift, resulting in a fractured left femur.
An employee was descending a fixed ladder into a block house to perform maintenance on a snow-making system. His foot slipped and his heel struck a pipe (part of the snow-making system) behind him. The employee fell partially down the ladder before he stopped himself from falling further and another employee helped him out of the space. The employee suffered a broken right tibia and fibula.
An employee was walking down stairs when he slipped and grabbed onto the railing to prevent himself from falling which resulted in injury to his left hip. The employee was hospitalized.
More severe injuries in this industry (NAICS 541330)
An employee was working to free a load by grabbing and shaking the live side of a tugger line. Once the load became free and progressed upward, the employee's hand was caught and pulled into a snatch block. The employee's right thumb was broken and lacerated. The employee was hospitalized and required a surgical amputation.
An employee was operating a drill rig when when their hand got caught between a 1/4-inch steel cable and a drill rod, resulting in the amputation of four fingers.
An employee was overseeing the operation of a rope being respooled onto the drum of a wire winding machine. He went to remove a piece of wooden reel from the rope. His glove got snagged and his right hand was pulled into the roller, pinching his fingers between the machine's roller and the rope. The middle and index fingers were crushed.
An employee was visiting a patient's home to fit them with a wearable cardiac defibrillator. As he was walking from the front door to his car, a large dog broke free from a chain and attacked him. He was bitten on the forearm and fell. The patient was then able to restrain the dog. The employee was hospitalized with severe dog bites and required surgery.
An employee tripped over a junior I-beam about 4 feet long and 6 inches tall that was installed for circulating water valves and fell to the ground, resulting in a broken right-side rib.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.