CARY, ILLINOIS—
TV GPMC, L.L.C.
Other fall to lower level 6 to 30 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at TV GPMC, L.L.C., 201 Jandus Rd., CARY, ILLINOIS 60013 on — Fractures , affecting the Part of body unspecified.
Final narrative
A maintenance employee was climbing a fixed roof access ladder to perform work on an HVAC unit when they fell from the ladder, over the second-floor railing, and onto the stairs below. The total distance of the fall was over 20 feet. The employee suffered multiple fractures that required hospitalization.
Similar incidents · Same event type
SYRACUSE, NEW YORK—
Cashless Tolling Constructors
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
JAMAICA, NEW YORK—
Cornell & Company, Inc.
An employee was standing on the surface of a steel beam about two feet wide. He slipped and fell backward, landing on the concrete ground about 20 feet below. The employee sustained a broken pelvis.
CRESTVIEW, FLORIDA—
Anderson Columbia Co., Inc.
An employee was cleaning out an inlet pipe in a stormwater structure. The employee stepped back, fell into the pipe, and landed on concrete 13 feet below, at the bottom of the structure. He suffered a broken back.
ATLANTA, GEORGIA—
Freeman Expositions, LLC
An employee was working on a platform, raised 6 to 8 feet in the air, to get something off a rack. The employee fell from the platform to the ground and sustained a head injury and injury to multiple body parts.
CANAL WINCHESTER, OHIO—
Faler Feed Store, Inc.
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
More severe injuries in this industry (NAICS 325510)
GREENSBORO, GEORGIA—
New England Wire Products Inc.
An employee was operating a shear to cut metal parts when two of their fingers contacted the blade. This resulted in amputation of the left middle and index fingertips.
SCRANTON, ARKANSAS—
Johnson Industrial Coatings, LLC.
On October 5, 2025, an employee was pulling a pressure washer hose when it it disconnected from the cooker. The employee was struck by jets of high-pressure water, resulting in lacerations to their left thigh requiring surgery. The employee was hospitalized.
ELLAVILLE, GEORGIA—
TCI, INC.
At about 8:00 p.m. on September 8, 2025, an employee was cleaning an extruder. While he was brushing built-up powder, his hand brushed the extruder screws. The screws caught his right index finger and amputated about a quarter inch of it.
NORTH KANSAS CITY, MISSOURI—
Tnemec Company, Inc.
At about 10:30 a.m. on August 7, 2025, a warehouse technician working for Tnemec Company, Inc., began sweating profusely a half-hour into their shift. The employee was using a forklift to move staged pallets of paint to a shrink-wrapper, shrink-wrap the pallets, and then load the pallets onto a truck using a forklift. The employee became ill about two hours later and was hospitalized for heat-related illness.
AVON, OHIO—
Advanced Polymer Coatings
An employee was transporting panels to a waste container using a powered industrial truck (PIT). The panels were stacked on the lifted forks of the truck. The employee stood on the panels to adjust them when they started to bow and the employee fell 6 feet to the ground, contacting the panel edges during the fall. The employee suffered lacerations to their left hand and both kneecaps, a collapsed right lung, and fractures to ribs 4 through 9 on the right side. The employee was hospitalized.
More severe injuries in ILLINOIS
ROUND LAKE, ILLINOIS—
Takeda Pharmaceuticals U.S.A., Inc.
An employee fell while moving a water canister, resulting in fractures to four fingers on her right hand.
KEWANEE, ILLINOIS—
Great Dane Ltd. Partnership
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
FRANKLIN PARK, ILLINOIS—
Olympia Food Industries Inc.
An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.
NORTH CHICAGO, ILLINOIS—
AbbVie Inc.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.
MONTGOMERY, ILLINOIS—
TSA Processing - Montgomery
A temporary employee was carrying a nail gun through the warehouse when it hit his leg, activated, and fired a nail into the leg.